Manuals / Cornelius / Kitchen Appliance / Beverage Dispenser

Cornelius 1550 Beer Inlet Lines Electrical Control Box Power Cord Terminal Block, Condenser Coil

Models: 1550

1 36

Download 36 pages 26.56 Kb

Page 23

Image 23

BEER INLET

LINES (2)

ELECTRICAL

CONTROL BOX

POWER CORD

TERMINAL

BLOCK

RETAINING

SCREW

ACCESS

GRILLE

CONDENSER

COIL

	UNIT POWER	CONDENSER
	SWITCH	CONDENSER
	SWITCH	FAN MOTOR
	(115 VAC	FAN MOTOR
	(115 VAC
	UNIT ONLY)
		COMPRESSOR

FIGURE 5. PARTS IDENTIFICATION

569000246

Page 23

Image 23

Cornelius 1550 Beer Inlet Lines Electrical Control Box Power Cord Terminal Block, Retaining Screw Access Grille, Condenser

Contents

IMI CORNELIUS INC g One Cornelius Place g Anoka, MN Installation Manual1550 UNIVERSAL BEER DISPENSER R-404A REFRIGERANT  IMI CORNELIUS INCGENERAL INFORMATION TABLE OF CONTENTSPage SAFETY INFORMATION INSTALLATIONWARRANTY TABLE OF CONTENTS cont’dPage SERVICE AND MAINTENANCE TROUBLESHOOTINGFollow Safety Instructions SAFETY INFORMATIONRecognize Safety Information Understand Signal WordsPage 569000246 THIS PAGE LEFT BLANK INTENTIONALLYDESIGN DATA WARRANTY REFERENCE INFORMATIONGENERAL INFORMATION GENERAL DESCRIPTIONFIGURE 1. 1550 UNIVERSAL BEER DISPENSER THEORY OF OPERATIONTable 1. Design Data cont’d TANK CONTAINING SANITIZING SOLUTION NOTE 1 THESE PARTS MUST BE INSTALLED IN UNIT BEERNOTE 2 THESE PARTS MUST BE INSTALLED IN THE CO2 LINE TO FACILITATE CONNECTING CO2 TO SYRUPPage 569000246 THIS PAGE LEFT BLANK INTENTIONALLYSELECTING LOCATION INSTALLATIONUNPACKING AND INSPECTION FILL WATER TANK AND START REFRIGERATION SYSTEM INSTALLATIONPREPARING UNIT FOR OPERATION CONNECTING CO2 SYSTEM TO BEER KEG TAPPERSCONNECTING BEER SOURCE SUPPLIES TO UNIT UNIT OPERATION OPERATING CONTROLS UNIT POWER SWITCH 115 VAC, 60 HZ UNIT ONLYOPERATOR’S INSTRUCTIONS PROPER BEER STORAGEADJUSTING DISPENSED BEER FLOW RATE ADJUSTMENTSCOOLING UNIT MAINTENANCE ADJUSTING CO2 REGULATORSREPLENISHING CO2 SUPPLY CLEANING AND SANITIZINGCLEANING CO2 SYSTEM GAS CHECK VALVES DAILY CLEANINGPage 569000246 THIS PAGE LEFT BLANK INTENTIONALLYADJUSTMENTS SERVICE AND MAINTENANCEPREPARING UNIT FOR SHIPPING, RELOCATING, OR STORING PERIODIC INSPECTIONDRIP TRAY DRAIN HOSE PLUG WATER TANK OVERFLOW TUBE WATER TANK UNIT BEER INLET LINES POWER CORD UNIT POWER SWITCH 115 VAC UNIT ONLYDRAIN HOSE RETAINING SCREW ACCESS GRILLE AIR INTAKE BEER FAUCET CUP REST DRIP TRAYSWITCH BEER INLET LINES ELECTRICAL CONTROL BOX POWER CORD TERMINAL BLOCKRETAINING SCREW ACCESS GRILLE UNIT POWERCORNELIUS BEER FAUCET PERLICK BEER FAUCET BEER FLOW RATE UNIT MAINTENANCE CLEANING CONDENSER COILBEER FLOW RATEADJUSTMENT ADJUSTMENT CHECKING ICE WATER BATH CLEANING WATER TANK9. Rinse all parts and flush water tank with clean water SANITIZE BEER SYSTEMSCLEANING AND SANITIZING DAILY CLEANINGREPLENISHING CO2 SUPPLY 5. Connect tank containing detergent solution into the beer systemQUAD RING BALL SPRING RETAINER BODY Quad ring seal must be replaced each time check valve is servicedREPLENISHING BEER SUPPLY 569000246 CLEANING CO2 GAS CHECK VALVEsee Figures 2 and 569000246 FIGURE 8. WIRING DIAGRAMTROUBLESHOOTING Trouble TROUBLESHOOTING COOLING UNIT REFRIGERATION SYSTEM Trouble 569000246 WARRANTYIMI Cornelius Offices IMI CORNELIUS INC301137000 One Cornelius Place Anoka, MinnesotaIMI CORNELIUS INC CORPORATE HEADQUARTERS

BEER INLET

RETAINING

CONDENSER

UNIT POWER

CONDENSER

SWITCH

FAN MOTOR

(115 VAC

UNIT ONLY)

COMPRESSOR