Manuals / Drolet / Household Appliance / Stove

Drolet ECO-35 Table Of Contents, Operation, Operating Safety Precautions, Maintenance

Models: ECO-35

1 30

Download 30 pages 54.73 Kb

Page 4

TABLE OF CONTENTS

TABLE OF CONTENTS
INTRODUCTION	2
SAFETY PRECAUTIONS	3
TABLE OF CONTENTS	4
STOVE INSTALLATION	6
ECO-35 FREESTANDING PELLET STOVE	6
CLEARANCES	6
COMBUSTION AIR SUPPLY	7
WHEN OUTSIDE AIR IS NOT USED	7
VENTING	7
EQUIVALENT VENT LENGHT (EVL)	8
INSTALLATION CONFIGURATIONS	8
HORIZONTALLY THROUGH WALL	8
VERTICALLY WITH NEW CHIMNEY SYSTEM	9
VERTICALLY INTO EXISTING CHIMNEY SYSTEM	9
VERTICALLY INTO EXISTING MASONRY FIREPLACE	10
INSTALLATION THROUGH SIDE OF MASONRY CHIMNEY	10
OPERATION	11
PROPER FUEL	11
PRE-START-UP CHECK	11
BUILDING A FIRE	11
LIGHTING PROCEDURE	11
UNIT CONTROLS	12
MODE BUTTON	12
FUEL FEED SWITCH	12
NOISE REDUCER	12
HEAT LEVEL	12
RESET	12
OPENING DOOR	12
CONVECTION BLOWERS (ROOM AIR FAN)	12
COMBEXtm	13
IF THE STOVE RUNS OUT OF PELLETS	13
REFUELING	13
SHUTDOWN PROCEDURE	13
SAFETY FEATURES	13
DAMPER OPERATION	14
OPERATING THE STOVE USING A THERMOSTAT	15
THERMOSTAT INSTALLATION	15
MODES	15
OPERATING SAFETY PRECAUTIONS	16
MAINTENANCE	17
ASH REMOVAL	17
ASH DISPOSAL	17
VACCUM USE	18
CLEANING	18
BLOWERS AND PRESSURE SWITCH PROBE	19
CHIMNEY CLEANING	19
RECOMMENDED MAINTENANCE SCHEDULE	19

4

Image 4

Drolet ECO-35 owner manual Table Of Contents, Operation, Operating Safety Precautions, Maintenance

Contents

CANADA Professional installation is highly recommendedMODEL ECO-35 FREESTANDING OWNER’S MANUAL Manufactured by Stove Builder International Inc Quebec City QuebecINTRODUCTION Keep this manual handy for future referenceSAFETY PRECAUTIONS TABLE OF CONTENTS SAFETY PRECAUTIONSOPERATING SAFETY PRECAUTIONS MAINTENANCETROUBLESHOOTING ELECTRICAL DIAGRAMREPLACEMENT PARTS DROLET LIMITED LIFETIME WARRANTYSTOVE INSTALLATION INSTALL VENT WITH CLEARANCES SPECIFIED BY THE VENT MANUFACTURERECO-35 FREESTANDING PELLET STOVE PREPARATIONWHEN OUTSIDE AIR IS NOT USED INSTALL VENT AT CLEARANCES SPECIFIED BY THE VENT MANUFACTURERWARNING DO NOT INSTALL IN SLEEPING ROOM COMBUSTION AIR SUPPLYINSTALLATION CONFIGURATIONS Venting through wallVenting trough wall EQUIVALENT VENT LENGHT EVLBasement installation Refer to Figure 9 & 10 for basement installationVenting through roof Venting through existing chimneyINSTALLATION THROUGH SIDE OF MASONRY CHIMNEY Venting through masonry chimneyVenting through side of masonry chimney VERTICALLY INTO EXISTING MASONRY FIREPLACEOPERATION LIGHTING PROCEDUREPROPER FUEL PRE-START-UP CHECKFUEL FEED SWITCH RESETUNIT CONTROLS OPENING DOORSHUTDOWN PROCEDURE SAFETY FEATURESCOMBEXtm IF THE STOVE RUNS OUT OF PELLETSBEFORE RESETING TO RESETSTOVE Damper operationTHERMOSTAT WIRE TERMINAL OPERATING THE STOVE USING A THERMOSTATTHERMOSTAT INSTALLATION D = MINIMUM DISTANCE 15 FEETOPERATING SAFETY PRECAUTIONS PLEASE READ THISMAINTENANCE Baffle & exhaust access panelCleaning rod Ash drawerBaffle removal CLEANINGVACCUM USE BLOWERS AND PRESSURE SWITCH PROBE CHIMNEY CLEANINGRECOMMENDED MAINTENANCE SCHEDULE DANGER RISK OF ELECTRIC SHOCK. DISCONNECT POWER BEFORE SERVICING UNITTROUBLESHOOTING REMOVAL AND REPLACEMENT OF BROKEN DOOR GLASSSTOVE SHUTS OFF AND SHOWS WARNING CODE “P” Possible CausesSTOVE SHUTS OFF AND DISPLAYS WARNING CODE “E” 3. The air damper is open too much for the low feed settingPossible Causes STOVE FEEDS PELLETS, BUT WILL NOT IGNITE AND SHOWS WARNING CODE “L” STOVE FEEDS PELLETS, BUT WILL NOT IGNITEAND SHOWS WARNING CODE “I” STOVE STOPS FEEDING PELLETS AND SHOWSTO RESET BEFORE RESETINGCODE Warning generated by a power failure while the stove was running The stove will restart on the initial setting once it cools offGLASS SOOTS UP VERY FAST FLAME IS LAZY, DARK, AND HAS BLACK TIPS AFTER STOVE HAS BEEN ON FOR A WHILE, THE BURNPOT OVERFILLSWARNING CODES SMOKE SMELL OR SOOT BUILD-UPMESSAGE CORRESPONDING WARNINGELECTRICAL DIAGRAM Electrical diagramComponents left side Components rearREPLACEMENT PARTS PART #HORIZONTAL AND VERTICAL VENT CHART APPENDIX APossible Vertical vent length feet Possible Horizontal vent length feetAPPENDIX B your installationDESCRIPTION OF THE PROBLEM InstallationDROLET LIMITED LIFETIME WARRANTY WARRANTY APPLICATIONPARTS LABOUR