Manuals / Enviro / Household Appliance / Stove

Enviro Cara Initial Installation, Qualified Installers Only, Common Horizontal Installation

Models: Cara

1 44

Page 15

Figure 24 Common Horizontal Installation.

Initial Installation
QUALIFIED INSTALLERS ONLY
PLANNING YOUR INSTALLATION:
Round Support
Box/Wall Thimble
Horizontal
Termination
Pipelength	Vertical
	Vertical
90° Elbow	Termination
90° Elbow
	Storm Collar
	Flashing
Pipelength	Ceiling Firestop
	Ceiling Firestop
Round Support
Box/Wall Thimble
Figure 24 Common Horizontal Installation.
	Cathedral Ceiling
	Support Box

	36" (915 mm)	Pipelength
	Snorkel	Pipelength
	Snorkel

Round Support

Pipelength

Box/Wall Thimble

Figure 25: Common Vertical Installation.

Onto Stove	2 ft (610 mm)
Adaptor	Pipelength

Figure 26: Common Snorkel Installation.

Page 15

Image 15

Enviro Cara Initial Installation, Qualified Installers Only, Common Horizontal Installation, 36 915 mm, Snorkel, Adaptor

Contents

CONSUMER INSTALLERDo not touch any electrical switch or use any phone in your building WHAT TO DO IF YOU SMELL GASSafety Precautions FOR YOUR SAFETYGENERAL Blower Speed Table of ContentsSafety Precautions SpecificationsTOP VENT DV Certified for installation from 0-4500 ft 0-1372 mCertified for installation from 0-4500 ft 0-1372 m with 36” 915 mm Codes And ApprovalsFigure 1 Cara Exterior Dimensions SpecificationsFOR YOUR SAFETY READ BEFORE OPERATING Operating InstructionsRESULT, CAUSING PROPERTY DAMAGE, PERSONAL INJURY OF LOSS OF LIFE Figure 3 Pilot AssemblyCara For Your Safety, Read Safety PrecautionsAnd Lighting Instructions Before Operating Operating InstructionsOperating Instructions ComponentSound & Reason For Your Safety, Read Safety PrecautionsMaintenance And Service Figure 9 Install the Rock Set Burner to the Firebox Maintenance And ServiceIMPORTANT Ensure the unit is off and at room temperature Figure 8 Install the Log Set Burner to the FireboxFigure 12 Firebox Baffle Screws Removal Maintenance And ServiceFigure 10 Align Log Set Burner With Firebox Figure 11 Align Rock Set Burner With FireboxConversion Kit Installation TO BE INSTALLED BY A QUALIFIED SERVICE AGENCY ONLYPlease read and understand these instructions before installing Kit Parts List7. Convert the SIT gas valve Maintenance And ServiceQUALIFIED INSTALLERS ONLY Initial InstallationFigure 25 Common Vertical Installation Initial InstallationQUALIFIED INSTALLERS ONLY Figure 24 Common Horizontal InstallationInitial Installation ManufacturerTrade Name Nominal SizesDirect-Temp Initial InstallationQUALIFIED INSTALLERS ONLY Direct Vent GSFigure 28 Vent Termination Restrictions, refer to Table NOTE Venting terminals shall not be recessed into walls or sidingInitial Installation QUALIFIED INSTALLERS ONLYInitial Installation VentFeet UnitofInitial Installation QUALIFIED INSTALLERS ONLY4. Re-install the firebox baffle and the door 2” 51mm at top, 11⁄2” 38mm at sides, 11⁄2” 38mm at bottom Initial InstallationQUALIFIED INSTALLERS ONLY Initial Installation QUALIFIED INSTALLERS ONLYf Maintain manufacturer’s clearances to combustibles with venting Initial Installation QUALIFIED INSTALLERS ONLY5. Cut hole in the roof centered on the small Initial Installation QUALIFIED INSTALLERS ONLY10. Twist-lock the vent cap Initial Installation QUALIFIED INSTALLERS ONLY1. Follow installation steps 1 & 2 under INITIAL Initial Installation QUALIFIED INSTALLERS ONLYDo not interfere with the structural integrity of the walls Initial Installation QUALIFIED INSTALLERS ONLYto a rear vented unit for use with a 36” Initial Installation QUALIFIED INSTALLERS ONLYSeal around the termination using a non-hardening mastic Natural Gas Venturi SettingGAS LINE CONNECTION TO TEST VALVE PRESSURESMax. Length Wire SizeELECTRICAL INFORMATION Canadian Installations U.S.A. Installations3. Install the temperature sensor into the holder Initial InstallationNOTE The logs are fragile and should be handled gently Secondary InstallationFigure 58 Log Placement Complete Secondary InstallationFigure 56 Log Placement of Left Log Figure 57 Log Placement of Center LogSecondary Installation CAUTION NEVER OPERATE THIS APPLIANCE WITH THE GLASS DOOR REMOVEDSecondary Installation CAUTION NEVER OPERATE THIS APPLIANCE WITH THE GLASS DOOR REMOVED3. The four 4 large rocks are placed across front Figure 66 Firebox Liners Installation Do not install when the unit is hotSecondary Installation Figure 65 Steel Firebox Liners InstallationPossible Cause Trouble ShootingProblem SolutionPart Parts ListReference Part DescriptionPart Parts ListReference Part DescriptionParts Diagram Limited One 1 Year Warranty WarrantyLimited Lifetime Warranty Limited Two 2 Year Warranty12. The Limited Warranty is void if Warranty22. Any statement or representation of VistaFlame products and their performance contained in VistaFlame advertising, packaging literature, or printed material is not part of the Limited Warranty Warranty6782 OLDFIELD RD. SAANICHTON, BC, CANADA V8M 2A3 Installation Data Sheet

Figure 24 Common Horizontal Installation.

36" (915 mm)

Snorkel

Figure 25: Common Vertical Installation.

Onto Stove

2 ft (610 mm)

Adaptor

Pipelength

Figure 26: Common Snorkel Installation.