Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster Accessories, J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS SERVICE PARTS, Part #

Models: J1X J2X

1 44

Download 44 pages 5.36 Kb

Page 41

Image 41

J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS

CHAPTER 8: SERVICE PARTS

8.4Accessories

ITEM	PART #	COMPONENT
1		Basket
	803-0019	Twin Basket, J1C & J1X
	803-0271	Twin Basket, J2X
2		Basket Support Rack
	803-0030	Basket Support Rack, J1C & J1X
	803-0032	Basket Support Rack, J2X
3	803-0197	Frypot Cleanout Rod
4	810-0069	Quick Disconnect, ½" Male
5	810-0071	Quick Disconnect, ½" Female
6		Flexible Gas Line
	810-0081	Flexible Gas Line, ½" x 36"
	810-0082	Flexible Gas Line, ½" x 48"
*	812-1227	Drain Nipple

* Not illustrated.

8-6

Page 41

Image 41

Frymaster manual Accessories, J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS SERVICE PARTS, Part #, Component, Basket

Contents

Installation, Operation, Service, and Parts NOVEMBER24-Hour Service Hotline service@frymaster.comNOTICE TO U.S. CUSTOMERS REQUIREMENTS in Chapter 2 of this manual for specificsNOTICE TO OWNERS OF UNITS EQUIPPED WITH COMPUTERS U.S CANADARETAIN AND STORE THIS MANUAL IN A SAFE PLACE FOR FUTURE USE CHAPTER 2 Installation Instructions TABLE OF CONTENTSCHAPTER 5 Preventive Maintenance CHAPTER 6 Operator Troubleshootingfrymaster domestic warranty J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.1 Parts Ordering and Service Information1.2 Safety Information 1.3 Equipment Description 1.4 Installation, Operating, and Service PersonnelJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 1 INTRODUCTION malfunction of your systemWarranty on your equipment 1.6 Shipping Damage Claim Procedure1.5 Definitions What to do if your equipment arrives damaged2.1 General Installation Requirements CHAPTER 2 INSTALLATION INSTRUCTIONSJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS open flame of any type, including those of broilers and rangesCHAPTER 2 INSTALLATION INSTRUCTIONS 2.1 General Installation Requirements contJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CLEARANCE AND VENTILATION DANGERDANGER DO NOT install this appliance without legs 2.2 Leg Installation2.3 Pre-Connection Preparations NATIONAL CODE REQUIREMENTS2.4 Connection to Gas Line 2.3 Pre-Connection Preparations contStandard Incoming Gas Pressure for J1C, J1X, and J2XCHAPTER 2 INSTALLATION INSTRUCTIONS Gas Connection Pipe SizesThe size of the gas line used for installation is very important. If the line is too small, the gas pressure at the burner manifold will be low. This may cause slow recovery and delayed ignition. The incoming gas supply line should be a minimum of ½ 13 mm in diameter. Refer to the chart below for the minimum sizes of connection piping J1C, J1X, & J2X MASTER JET SERIES GAS FRYERSStandard Burner Manifold CHAPTER 2 INSTALLATION INSTRUCTIONS DANGERGas Pressure for J1C, J1X, and J2X Pressure - J2Xdefined in Section 1.6 of this manual Gas Conversion Instructions 2.5 Converting to Another Gas Typefor J1C Fryers only Natural to PropaneACCESSING THE PILOT 3.1 Start-Up ProcedureCHAPTER 3 OPERATING INSTRUCTIONS Solid shortening must be pre-melted prior to filling frypotLighting the Pilot 3.1 Start-Up Procedure contCHAPTER 3 OPERATING INSTRUCTIONS LIGHTING THE PILOT3.2 Boiling-Out the Frypot Cycle mode until the Melt Cycle switch is placed in the OFF positionCHAPTER 3 OPERATING INSTRUCTIONS MELT CYCLE Boiling-Out the Frypot3.3 Shutting Down the Fryer 3.2 Boiling-Out the Frypot contJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 3 OPERATING INSTRUCTIONS4. Filtration CHAPTER 4 FILTRATION INSTRUCTIONSappropriate container for disposal DANGER above the maximum fill line located on the containerCHAPTER 4 FILTRATION INSTRUCTIONS 4. Filtration contoil/shortening will rush out, creating an extreme hazard J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS5.1 Fryer Preventive Maintenance Checks and Services CHAPTER 5 PREVENTATIVE MAINTENANCEDAILY CHECKS AND SERVICES Inspect Fryer and Accessories for Damage Clean Fryer Cabinet Inside and Out DANGERCHAPTER 5 PREVENTATIVE MAINTENANCE 5.1 Fryer Preventive Maintenance Checks and Services contQUARTERLY CHECKS AND SERVICES Drain and Clean Frypot Clean Detachable Parts and AccessoriesSEMI-ANNUAL CHECKS AND SERVICES Check Burner Manifold Pressure DANGER Clean Gas Valve Vent Tubearrange this service 5.1 Fryer Preventive Maintenance Checks and Services contJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS 5.2 Annual/Periodic System InspectionCHAPTER 5 PREVENTATIVE MAINTENANCE PROBLEM 6.2 Troubleshooting Thermostat Controlled Fryers6.1 Introduction oil/shortening from one container to anotherCHAPTER 6 OPERATOR TROUBLESHOOTING 6.3 Troubleshooting Abnormal Burner OperationPROBABLE CAUSES CORRECTIVE ACTIONFlame rolling out CHAPTER 6 OPERATOR TROUBLESHOOTINGJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS Pilot outage 7. Service Procedures CHAPTER 7 SERVICE PROCEDURESJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS Figure 1 Cabinet InteriorWhen installing thermostats, DO NOT OVER TORQUE CHAPTER 7 SERVICE PROCEDURES7.2 Calibrating a Thermostat after Installation 7.1 Replace Controlling or High-limit Thermostat7.3 Replace the Pilot Generator Cartridge 7.4 Adjust Pilot FlameNOTE Thermopile should NOT glow red CHAPTER 7 SERVICE PROCEDURES7.6 Replacing the Fryer Gas Valve CHAPTER 7 SERVICE PROCEDURES 7.5 Burner Gas Pressure AdjustmentJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS 1. Turn the gas valve knob to the PILOT position7.8 Replacing Burner Deflector 7.7 Removing the Main Burner AssemblyCHAPTER 7 SERVICE PROCEDURES J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS7.10 Replacing the Frypot 7.9 Alignment & Adjustment of Metal Burner DeflectorCHAPTER 7 SERVICE PROCEDURES J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS8.1 Main Components J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTSPART # COMPONENTJ1C & J1X J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTS8.2 Frypot Components Flue Assembly, J2X J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTSDrain Valve, J1C & J1X Full Assembly Drain Valve, J2X Full AssemblyJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTS J1C & J1X Burner Manifold Assembly J2X Burner Manifold Assembly8.3 Burner Components Pilot Assembly CHAPTER 8 SERVICE PARTSJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS PART #J1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTS 8.4 AccessoriesPART # COMPONENTJ1C, J1X, & J2X MASTER JET SERIES GAS FRYERS CHAPTER 8 SERVICE PARTS 8.5 Thermostat ComponentsThermostat Assembly Kit includes Items 2 and Thermostat Dial Plate AssemblyTHIS PAGE INTENTIONALLY LEFT BLANK Frymaster L.L.C, 8700 Line Avenue, Shreveport, Louisiana SERVICE HOTLINEFAX Parts FAX Tech Support

8.4Accessories

Basket

Basket Support Rack

Flexible Gas Line