Manuals / Frymaster / Kitchen Appliance / Fryer

Frymaster TB14 operation manual Air Supply and Ventilation, Equipment Installed at High Altitudes

Models: TB14

1 60

Download 60 pages 19.35 Kb

Page 11

Image 11

Image 11

Frymaster TB14 operation manual Air Supply and Ventilation, Equipment Installed at High Altitudes, Pre-Installation cont

Contents

8195941 PARTS LIST INCLUDEDTB14 Series With Built-In Filtration Installation & Operation Manual REQUIREMENTS in Chapter 3 of this manual for specifics other appliance DANGER from slips or contact with the hot oil DANGER Page # TABLE OF CONTENTSTB14 Series Gas Fryers TABLE OF CONTENTS CONT 1.2 Ordering Parts 1.3 Service InformationTB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.1 After Purchase TB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.5 Safety Information1.6 Service Personnel 1.4 Computer Information cont TB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.6.1 Definitions cont B. Qualified Installation PersonnelC. Qualified Service Personnel 2.2 Principles of Operation 2.4 Pre-InstallationTB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.1 Product Description TB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.4 Pre-Installation contC. Installation Standards A. Do not connect this fryer to an exhaust duct 2.6 Equipment Installed at High Altitudes2.5 Air Supply and Ventilation If your equipment arrives damaged 2.7 Receiving and Unpacking Equipment movement to avoid damage and possible bodily injury DANGER TB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION3.1 Installing the Fryer 3.2 Leveling the Fryer fryers equipped with legs only Questions? Call 3.3 Installing Casters and LegsTB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION Recommended Gas Supply Line Sizes 3.4 Gas ConnectionsNATIONAL CODE REQUIREMENTS damage to the fryer’s gas piping and gas valves 3.4 Gas Connections cont½ PSI 3.45 kPa/35 mbar, a step-down regulator will be required I. Flexible Couplings, Connectors and Casters new connectionsinjury may result 3.5 Electrical Connections 4.1 Initial Start-up 4.1.1 Pilot Lighting Procedures, Standing Pilot OnlyTB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS TB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS 4.1.1 Pilot Lighting Procedures, Standing Pilot Only cont 4.2 Boil-Out Procedure crack glass containers 4.2 Boil-Out Procedure contso will damage the heating tubes and frypot, and void the warranty 4.3 Final Preparation transfer TB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATION TB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATION 5.1 General 5.2.1 Assembling the Filter 5.2 Filtration Preparation Assemble the filter as follows 5.2.1 Assembling the Filter cont 4. Sprinkle 8 ounces of filter powder on the filter sheet. Ensure the powder covers the filter paper evenly 5.3.1 General Overview 5.2.2 Installing the Filter5.3 Daily Filtration Operation container for disposal 5.4 Operating the Filter5.3.2 Filtering Tools shortening will rush out creating the potential for severe burns 5.4 Operating the Filter contoverflow and spillage of hot oil/shortening DANGER above the maximum fill line located on the container DANGER 1. Turn the fryer off. Ensure the filter pan assembly is prepared as described in Section 5.2.1- Assembling the Filter 5.4.2 Filter Operationtemperature ~350F ~177C 5-10 5.4.2 Filter Operation cont 5-11 5-12 DO NOT ALLOW CRUMBS TO ACCUMULATE IN TRAY 5-13 DESCRIPTION TB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATION6.1 Operating Fryers with Computer Magic III.5 Computers water. NEVER allow water to enter the Filtration System Shutdown 6.1.1 Equipment Setup and Shutdown ProceduresSetup TB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATION results, do not cook product until the display reads 6.1.1 Equipment Setup and Shutdown Procedures contDo not cancel the melt cycle mode if using solid shortening 6.1.2 Checking Temperature 6.2 Programming the Computer Magic III.5 Computer 6.2 Programming the Computer Magic III.5 Computer cont 6.2.1 Boil Feature 6.2.3 Constant Oil Temperature Display Mode 6.2.1 Boil Feature contSEE CHAPTER 4.2 FOR ADDITIONAL BOIL-OUT PROCEDURES 6.2.2 Temperature Selection-Fahrenheit to Celsius 7.2 Daily TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCEtime the cleaner remains on the food-contact surfaces 7.1 General Built-in Filtration TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCE7.4 Periodic/Annual burns 7.4 Periodic/Annual cont7.5 Stainless Steel Care Built-in Filtration cont authorized service agent only TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTINGtests are required. Use extreme care when performing such tests Disconnect all power cords before servicing 8.3 Main Burner Malfunctions TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTING8.2 Pilot Burner Malfunction cont 8.3 Main Burner Malfunctions cont TB14 Series WiringDiagrams 8.4.1 Terminal #2 - Medium 8.4.2 TB14 Series Interface Board Enlarged ViewDual Operation Only COMPONENT TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LIST9.1 Accessories PART # 9.2 Cabinetry and Related Components TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LIST 1 823-3248 Support, Leg- Without Optional SUFF Filter Only 9.2 Cabinetry and Related Components cont 9.3 Computer and Related Components To Filter 9.4 Filter Module ComponentsTo Frypot 9.4 Filter Module Components cont 9.5 Filter Pan Components 9.6 Frypot, Burners and Related Components 9.6 Frypot, Burners and Related Components cont 9.7 Oil Return Components Price $10.00 SERVICE HOTLINEShipping Address 8700 Line Avenue, Shreveport, Louisiana FAX Parts 1-318-219-7140 FAX Tech Support