Filter Operation, Temperature ~350F ~177C | Frymaster TB14 instruction

Image 31

Frymaster operation manual Filter Operation, temperature ~350F ~177C, TB14 SERIES GAS FRYERS BUILT-IN FILTRATION

Contents

8195941 PARTS LIST INCLUDEDTB14 Series With Built-In Filtration Installation & Operation Manual REQUIREMENTS in Chapter 3 of this manual for specifics other appliance DANGER from slips or contact with the hot oil DANGER TB14 Series Gas Fryers TABLE OF CONTENTSPage # TABLE OF CONTENTS CONT 1.2 Ordering Parts 1.3 Service InformationTB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.1 After Purchase TB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.5 Safety Information1.6 Service Personnel 1.4 Computer Information cont C. Qualified Service Personnel B. Qualified Installation PersonnelTB14 SERIES GAS FRYERS CHAPTER 1 INTRODUCTION 1.6.1 Definitions cont 2.2 Principles of Operation 2.4 Pre-InstallationTB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.1 Product Description C. Installation Standards 2.4 Pre-Installation contTB14 SERIES GAS FRYERS CHAPTER 2 IMPORTANT INFORMATION 2.5 Air Supply and Ventilation 2.6 Equipment Installed at High AltitudesA. Do not connect this fryer to an exhaust duct If your equipment arrives damaged 2.7 Receiving and Unpacking Equipment movement to avoid damage and possible bodily injury DANGER TB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION3.1 Installing the Fryer 3.2 Leveling the Fryer fryers equipped with legs only TB14 SERIES GAS FRYERS CHAPTER 3 INSTALLATION 3.3 Installing Casters and LegsQuestions? Call NATIONAL CODE REQUIREMENTS 3.4 Gas ConnectionsRecommended Gas Supply Line Sizes ½ PSI 3.45 kPa/35 mbar, a step-down regulator will be required 3.4 Gas Connections contdamage to the fryer’s gas piping and gas valves injury may result new connectionsI. Flexible Couplings, Connectors and Casters 3.5 Electrical Connections TB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS 4.1.1 Pilot Lighting Procedures, Standing Pilot Only4.1 Initial Start-up TB14 SERIES GAS FRYERS CHAPTER 4 FRYER OPERATIONS 4.1.1 Pilot Lighting Procedures, Standing Pilot Only cont 4.2 Boil-Out Procedure crack glass containers 4.2 Boil-Out Procedure contso will damage the heating tubes and frypot, and void the warranty 4.3 Final Preparation transfer TB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATION TB14 SERIES GAS FRYERS CHAPTER 5 BUILT-IN FILTRATION 5.1 General 5.2.1 Assembling the Filter 5.2 Filtration Preparation Assemble the filter as follows 5.2.1 Assembling the Filter cont 4. Sprinkle 8 ounces of filter powder on the filter sheet. Ensure the powder covers the filter paper evenly 5.3 Daily Filtration Operation 5.2.2 Installing the Filter5.3.1 General Overview 5.3.2 Filtering Tools 5.4 Operating the Filtercontainer for disposal shortening will rush out creating the potential for severe burns 5.4 Operating the Filter contoverflow and spillage of hot oil/shortening DANGER above the maximum fill line located on the container DANGER temperature ~350F ~177C 5.4.2 Filter Operation1. Turn the fryer off. Ensure the filter pan assembly is prepared as described in Section 5.2.1- Assembling the Filter 5-10 5.4.2 Filter Operation cont 5-11 5-12 DO NOT ALLOW CRUMBS TO ACCUMULATE IN TRAY 5-13 DESCRIPTION TB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATION6.1 Operating Fryers with Computer Magic III.5 Computers water. NEVER allow water to enter the Filtration System Shutdown 6.1.1 Equipment Setup and Shutdown ProceduresSetup TB14 SERIES GAS FRYERS CHAPTER 6 COMPUTER OPERATION Do not cancel the melt cycle mode if using solid shortening 6.1.1 Equipment Setup and Shutdown Procedures contresults, do not cook product until the display reads 6.1.2 Checking Temperature 6.2 Programming the Computer Magic III.5 Computer 6.2 Programming the Computer Magic III.5 Computer cont 6.2.1 Boil Feature 6.2.3 Constant Oil Temperature Display Mode 6.2.1 Boil Feature contSEE CHAPTER 4.2 FOR ADDITIONAL BOIL-OUT PROCEDURES 6.2.2 Temperature Selection-Fahrenheit to Celsius 7.2 Daily TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCEtime the cleaner remains on the food-contact surfaces 7.1 General 7.4 Periodic/Annual TB14 SERIES GAS FRYERS CHAPTER 7 PREVENTATIVE MAINTENANCEBuilt-in Filtration burns 7.4 Periodic/Annual cont7.5 Stainless Steel Care Built-in Filtration cont authorized service agent only TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTINGtests are required. Use extreme care when performing such tests Disconnect all power cords before servicing 8.2 Pilot Burner Malfunction cont TB14 SERIES GAS FRYERS CHAPTER 8 TROUBLESHOOTING8.3 Main Burner Malfunctions 8.3 Main Burner Malfunctions cont TB14 Series WiringDiagrams 8.4.1 Dual Operation Only 8.4.2 TB14 Series Interface Board Enlarged ViewTerminal #2 - Medium COMPONENT TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LIST9.1 Accessories PART # 9.2 Cabinetry and Related Components TB14 SERIES GAS FRYERS CHAPTER 9 PARTS LIST 1 823-3248 Support, Leg- Without Optional SUFF Filter Only 9.2 Cabinetry and Related Components cont 9.3 Computer and Related Components To Frypot 9.4 Filter Module ComponentsTo Filter 9.4 Filter Module Components cont 9.5 Filter Pan Components 9.6 Frypot, Burners and Related Components 9.6 Frypot, Burners and Related Components cont 9.7 Oil Return Components Price $10.00 SERVICE HOTLINEShipping Address 8700 Line Avenue, Shreveport, Louisiana FAX Parts 1-318-219-7140 FAX Tech Support

Frymaster TB14 operation manual Filter Operation, temperature ~350F ~177C

Models: TB14