Heat & Glo LifeStyle EXCLAIM-36H-C, EXCLAIM-36T-C instruction

This page intentionally left blank.

46	Heat & Glo • EXCLAIM-36C Woodburning Fireplace • 4013-093 Rev G • 08/06

Image 46

Heat & Glo LifeStyle EXCLAIM-36H-C, EXCLAIM-36T-C owner manual This page intentionally left blank

Contents

EXCLAIM-36H-C EXCLAIM-36T-C Fire Risk Grate Listing Label Information/LocationNumber Table of Contents Appliance Certiﬁcation Listing and Code ApprovalsNot intended for use as a primary heat source Negative Pressure Design and Installation ConsiderationsGetting Started Asphyxiation Risk Marginal Location Typical Fireplace System Typical Fireplace System Inspect Fireplace and Components Tools and Supplies NeededFire Risk Explosion Risk Framing and Clearances Selecting Fireplace Location Clearances Failure to comply may cause ﬁre Sidewalls/Surrounds Frame the Fireplace Construct the Chase Chimney Requirements Fire Risk Sharp Edges Asphyxiation Risk Installation of FireplaceInstall the Outside Air Kit Risk of Smoke Spillage Ft min. from top of uppermost chimney section to air inlet Place the Protective Metal Hearth Strips Secure the FireplacePosition the Fireplace Level the Fireplace Chimney Assembly Height of Chimney Components Using Offsets/Returns ¨ Table Install the Ceiling Firestops Assemble the Chimney Sections Double-check the Chimney Assembly Install the Attic Insulation ShieldSecure the Chimney Complete the Enclosure Chimney Termination Install the Chimney Air Kit required in Canada Install the Termination CapChase Top Installing an ST475 Square Termination Cap Gas Log/Lighter Provisions AccessoriesGas Code, Ansi Z223.1 Finishing Hearth Extension Raised Hearth Extension Glass Doors Finishing MaterialMantel Combustible Material Operating Instructions General Information Flue Damper Outside AirClear Space Near the Fireplace Firescreen Firewood GrateWood Fuel Moisture Starting a Fire Troubleshooting Understanding Vent Problems Solutions Diagnostics and Problem SolvingDiagnostic Questions Can’t get a good ﬁre going. What am I doing wrong? ﬁreplace burns the wood too fast. What can I do? Disposal of Ashes Maintenance and Servicing the FireplaceChimney Inspection/Cleaning Firebox Refractory Clean Maintenance Task ListWhen cleaning glass door Chimney Fire Fireplace Dimensions Reference Materials Fireplace Components Catalog # Description Chimney Components Catalog # 330 mm 51 mm 14-3/4 375 mm This page intentionally left blank TR442 TR442 / 444 TV Minimum Base Dimensions 28 X 28 with 32 X 32 with 23 XMinimum Base Dimensions 26.5 X 28 with 34 X 34 with 20 x Service Parts EXCLAIM-36-C Series Service Parts Description of Part EXCLAIM-36T-C EXCLAIM-36H-C Qty.req This page intentionally left blank Warranty For Heat & GLO Fireplaces Limited Warranty Contact Information Do Discardnot