Hitachi E43 NOTE If the oil level is too low, the oil alert, English, Engine Oil, Oil Capacity

English

ENGINE OIL

NOTE: There is no oil in the engine crankcase when the generator is shipped. You must add oil before starting the engine. Check the oil level before each use with the generator on a level surface and the engine stopped.

Engine oil is a major factor affecting engine performance and service life. Non-detergent and 2-stroke oils will damage the engine and are not recommended. Use 4-stroke motor oil that meets or exceeds the requirements for API service classification SJ or SL. Always check the API SERVICE label on the oil container to be sure it includes the letters SJ or SL. SAE 10W- 30 is recommended for general, all-temperature use. Other viscosities shown in Fig.6 may be used when the average temperature in your area is within the indicated range.

CHECKING THE OIL (Fig.7 AND 8)

1. Remove the oil filler cap and wipe the dipstick clean. 2. Check the oil level by inserting the dipstick into the filler neck

without screwing it in.

3. If the test shows no oil markings, the oil is low.

4. If the level is low, add the recommended oil to the upper mark on Fig.6 the dipstick.

OIL CAPACITY

HITACHI Model	Quarts	Liters
E43	1.16	1.10
E60	1.16	1.10
E71	1.16	1.10

NOTE: If the oil level is too low, the oil alert

system will shutdown the engine and Fig.7 prevent engine from restarting.

FILLER CAP/DIPSTICK

UPPER LIMIT

FUEL Fig.8 LOWER LIMIT

WARNING: Gasoline is flammable and its vapor is explosive. To prevent fire or explosion, follow the guidelines below:

•Keep fuel out of the reach of children.

•Refuel the generator in well-ventilated area. Do not refuel while engine is running or hot. Disconnect all electrical loads and shut off the engine before refueling.

•Do not overfill the fuel tank. Always allow room for fuel vapors to expand. If you overfill the tank, fuel can overflow onto the hot engine. This can cause fire or explosion. After refueling, tightly close the fuel tank cap.

•Do not spill fuel. Fuel or fuel vapor may ignite. If fuel spills, make sure that the area is dry before starting the engine.

•Never smoke in the refueling area. Never allow open flames or sparks in area.

•Store fuel in an approved container. Store fuel in a well ventilated area free of open flames or sparks.

FUEL TANK CAPACITY

HITACHI Model	Gallons	Liters
E43	5.0	18.9
E60	5.0	18.9
E71	5.0	18.9

Check the fuel gauge located on the top of the generator near the fuel tank and refill the tank if the fuel level is low. Refuel carefully to avoid spilling fuel. Do not fill above the shoulder of the fuel strainer (Fig.9).

Use unleaded gasoline with a pump octane rating of 86 or higher. The Honda engine is certified to operate on unleaded gasoline. Unleaded gasoline produces fewer engine and spark plug deposits and extends exhaust system life. Never use stale or contaminated gasoline. Avoid getting dirt or water in the fuel tank.

Always keep the fuel strainer in place while refueling.

FUEL STRAINER

UPPER LEVEL (STRAINER SHOULDER)

Fig.9

9