Honeywell MS2420, MS2430 manual

MS2420 / MS2430

Bar Code Scanner / Diva Scale

Installation and User’s Guide

Contents

Page Disclaimer Trademarks Patents Table of Contents Scanner Operation Scale Operation Maintenance Troubleshooting Scanner and Cable Terminations Introduction Base Kit Components Optional Accessories Page Page Replacement Parts General Precautions Do not turn Do not press Platter Removal Finger Recesses Design Specifications Electrical Scale Capacities Environmental Base Model Characteristics MS2420/MS2430 Scanner / Mettler-ToledoDIVA Scale Components Item No Description of Item in Figure MS2420/MS2430 Scanner / Mettler-ToledoDIVA Scale MS2420 Dimensions Figure 7. MS2420 Dimensions MS2430 Dimensions Figure 8. MS2430 Dimensions Connector Panel MS2420/MS2430 Scanner/Diva Scale Caution and Serial Number Labels Caution: Page Installation Service Access Power Installation Checkout Counter Layout Considerations Unpacking the Unit Important! Do not MS2420/MS2430 Package Warning must Note: If the unit is going to be reshipped at any time this foam be reinstalled prevent damage to the scale arms during shipping MS2420 Mounting Diagram MS2430 Mounting Diagram (Two Point Support) MS2430 Mounting Diagram (Three Point Support) Cable Installation (Interface Specific) RS232 Stop 9.Turn on the host system 10.Scan the Recall Defaults bar code 11. Configure the scanner to match the host system’s RS232 parameters Figure 19. RS232 Interface Cable Installation Schematic Full Speed USB For USB Serial Emulation Mode or Keyboard Emulation Mode Only Figure 20. USB Cable Installation Schematic RS485 Configure the scanner to match the host system’s RS485 parameters Figure 21. RS485 Cable Installation Schematic Cable Installation (Secondary Honeywell Scanner) Refer to pages Connect the straight end of the RS232 PowerLink AUX cable (PN Connect the angled end of the RS232 AUX cable (PN Refer to the MS2x20 Stratos Series Scanner/Diva Scale Configuration Addendum Figure 22. Secondary Scanner Cable Installation Schematic EAS Deactivation Base Model Checkpoint Recommended Switch Bank Settings Page Scanner Operation Page Wake Activation Area (Photocell LED Output) Wake Activation Area Sensitivity (Photocell LED Output Range) Changing the Wake Area Sensitivity Level (Photocell LED Range Adjust) One Beep Razzberry Tone Three Beeps - during operation Three Beeps - on power up No Blue LED Steady Blue Steady Blue and Single blue Flash Flashing Blue Blue LED Off Flashing Blue and One Razzberry Tone Flashing Blue and Two Razzberry Tones Continuous Razzberry Tone with Both LED Off Three Beeps - On Power Up Diagnostic Indicator Display Error Code Page Page Power Save Modes Changing the Beeper Tone Changing the Beeper Volume The Multi-FunctionButton Startup Power-UpTest Mode Configuration Mode Page Scale Operation Calibration Tools Required Scale Calibration Methods Scale Calibration with Remote Display Bar Code Scale Calibration without Remote Display Priming the Scale for Calibration (lbs. or kg) Scale Calibration Procedure (lbs. or kg) with Remote Display Group 1 Step 8 (x) Selectable Weight Unit Ranges Need to Start Over Bar Code Calibration Procedure without Remote Display Page Unit Calibration (Pounds) Unit Calibration (Kilograms) Page Page Calibration Verification U.S. Pounds (lbs.) Increasing Load Test Kilograms (kg) Increasing Load test Security Seal Installation Pressure Sensitive Security Seal Wire Security Seal (Seal Conversion Kit PN 46-00359) Page Maintenance Daily Maintenance Troubleshooting Page Page Page Scanner and Cable Terminations Scanner Scale Pinout Connections Function Function Cable Connector Configurations Function† Regulatory Compliance EMC Emissions Immunity Class A Devices Folgendes trifft zu, wenn das Scannerkabel länger als 3 Meter ist: Attenzione Attention Class B Devices Folgendes trifft zu, wenn das Scannerkabel kürzer als 3 Meter ist: Reorient or relocate the receiving antenna Page Limited Warranty Page Index power 2, 7, 15, 16, 22–28,65, 69 43 regulatory compliance ...................................72–75 Customer Support Page Page Honeywell Scanning & Mobility