Manuals / Johnson Controls / Household Appliance / Furnace

Johnson Controls YP8C/YPLC*MP Johnson Controls Unitary Products York Drive Norman, OK

Models: YP8C/YPLCMP TP8C/TPLCMP LP8C/LPLCMP CP8C/CPLCMP

1 32

Page 32

Subject to change without notice. Printed in U.S.A.	368262-UIM-B-1008
Copyright © 2008 by Johnson Controls, Inc. All rights reserved.	Supersedes: 368262-UIM-A-0508

Johnson Controls Unitary Products

5005 York Drive

Norman, OK 73069

Page 32

Image 32

Johnson Controls YP8C/YPLC*MP, LP8C/LPLC*MP, TP8C/TPLC*MP Johnson Controls Unitary Products York Drive Norman, OK

Contents

Section I Safety ModelsList of Sections List of FiguresAnce to a 50 HZ Power Supply or a Voltage Above 130 Volts Specific Safety Rules and PrecautionsSafety Requirements Combustion AIR Quality List of Contaminants Codes and StandardsInspection Furnace Location and ClearancesFloor Base and Ductwork Installation Downflow Section II DuctworkDuctwork General Information Duct FlangesDownflow Duct Connectors Bottom Return and Attic InstallationsAttic Installation Suspended Furnace / Crawl Space InstallationDownflow Application Coil InstallationCOIL/FURNACE Assembly MC/FC/PC Series Coils Furnace Assembly MC & FC Series Coils Coil Flange InstallationFurnace Assembly MC Series Coils only Furnace Assembly PC Series CoilsFilter Installation Attempt to install filters inside the furnaceSection III Filters Side ReturnGAS Safety GAS Piping InstallationSection IV GAS Piping Horizontal FiltersSection V Electrical Power Electrical Power ConnectionsGAS Conversion for Propane LP High Altitude Natural GAS Orifice ConversionLOW Voltage Control Wiring Connections Supply Voltage ConnectionsAIR Conditioner Connections Max OutletThermostat ID ModelsModulating TWO Stage AIR Furnace Conditioner UIM-B-1008 Modulating Furnace OD Models Single Stage Heat PumpThermostat Modulating Furnace TWO Stage Heat PumpSection VI Vent System FAN-ASSISTED Combustion System Ambient Combustion Air SupplyCombustion Air Source From Outdoors Dampers, Louvers and Grilles Canada OnlyVentilated Combustion Air Vent and Supply Outside Air Safety Check ProcedureAir Supply Openings and Ducts GAS Piping Leak Check Section VII START-UP AdjustmentsNOx Screen Removal Lo-NOx Models Only Setup Test Mode Calculating the Furnace Input Natural GASRevolution Cu Ft Seconds For Size of Test Dial Revolution Cu FtSeconds For Adjustment of Manifold GAS Pressure Adjustment of Temperature RiseAdjustment of FAN Control Settings EAC100C20 060A12 080B12 Jumper Settings080C16 Section Viii Safety Controls Normal Operation Sequence Section IX Normal Operation and DiagnosticsFurnace Control Diagnostics Fabricated Parts Section X Replacement Parts ListDiagnostic Fault Code Storage and Retrieval Section XI Wiring Diagram Wiring DiagramJohnson Controls Unitary Products York Drive Norman, OK