Chassis and Front Cover Reassembly | Motorola 6816101H01-A manual

Radio Reassembly — Detailed

2-9

7.2Chassis and Front Cover Reassembly

NOTE Proceed to perform steps 1, 2, 3 and 4 only if there is a need to replace the speaker, speaker bracket or speaker felt.

1.Place the speaker felt onto the grille area (see “Figure 2-8”) .

2.Place the speaker on top of the felt.

Figure 2-8

3.Stick the speaker poron pad onto the back of speaker magnet.

4.Place the speaker bracket and screw the bracket to the housing.

NOTE Proceed to perform steps 5, 6, 7 and 8 only if there is a need to replace the latch.

5.Slot the battery latch shaft into the latch (see “Figure 2-9”).

Figure 2-9

6.Place the latch onto the housing, with the shaft protruding on the right side of the latch (see “Figure 2-10”).

Image 25

Motorola 6816101H01-A service manual Chassis and Front Cover Reassembly

Contents

Mag One by Motorola Radio Series Computer Software Copyrights Document History Page Federal Communication Commission FCC Regulations Safety Information Guidelines Compliance with RF Exposure Standards Electromagnetic Interference/Compatibility Hearing Aids Operational WarningsOther Medical Devices Use of communication devices while driving Intrinsically Safe Radio Information Operational CautionsOperational Cautions for Intrinsic Safe Equipment Repair Do Not Substitute Options or Accessories Table of Contents Glossary of Terms Radio Programming Warranty Period and Return Instructions Warranty and Service SupportIntroduction Scope of Manual Piece Parts After Warranty PeriodTechnical Support Further Assistance From Motorola Unit Level Radio Model Information CPS Radio Features Preventive Maintenance MaintenanceCleaning Procedures Introduction Safe Handling of Cmos and Ldmos Devices Repair Procedures and Techniques General Disassembling and Reassembling the Radio General Radio Disassembly Detailed Radio Disassembly DetailedFront Cover from Chassis Disassembly Speaker Wire Radio Disassembly Detailed PC Board Disassembly Radio Reassembly DetailedPC Board Reassembly Chassis and Front Cover Reassembly Radio Reassembly Detailed Speaker Connector Exploded View and Parts List Mechanical View and Parts ListReference Part Name Qty Reference Part Name Qty Reference Part Name Qty PMUD2221A PMNN4071RC Motorola Part Service AidsDescription Application Test Equipment Motorola Description Characteristics ApplicationProgramming Cable PMDN4043R Test Box PMDN4040R Cloning Cable PMDN4060R otes Radio Tuning Tuning Frequency Hardware Tuning Setup and Procedure Ground Contact Finger R425 R426 R216 FL701 R215 TP1 Subtone Level 42 ± 0.02kHz 96 ± 0.02kHz R425 R426 C722 Page Programming Your Radio Radio Programming Kit Number CPS Programming CPS Programming Setup Factory Reset Factory Reset Accessories Service Kits Audio AccessoriesPublications VHF Band 1 Information 136-150 MHz A8 136-150 MHz VHF Model Chart and Test SpecificationModel Description LAH84JDC8AA4AN General SpecificationsTransmitter Receiver LAH84KDC8AA4AN VHF Band 2 Information 150 174 MHz A8 150-174 MHz VHF Specifications LAH84QCC8AA4AN UHF Band 1 Information 403-425MHz A8 403-425 MHz UHF UHF UHF Band 2 Information 450 470MHz A8 450-470 MHz UHF Specifications LAH84TCC8AA4AN UHF Band 4 Information 490 512 MHz A8 490-512 MHz UHFPMAE4028A Specifications Glossary of Terms ResetTerm Definition PLL TPL ROMUHF VHF