Periodic Maintenance Chart | Polaris 550 EPS specs

MAINTENANCE

Periodic Maintenance Chart

Careful periodic maintenance will help keep your vehicle in safe, reliable condition. Inspect, clean, lubricate, adjust and replace parts as necessary. When inspection reveals the need for replacement parts, use genuine POLARIS parts available from your POLARIS dealer. Record maintenance and service in the Maintenance Log beginning on page 158.

Service and adjustments are important for proper vehicle operation. If you're not familiar with safe service and adjustment procedures, have a qualified dealer perform these operations.

Maintenance intervals in the following chart are based upon average riding conditions and an average vehicle speed of approximately 10 miles per hour. Vehicles subjected to severe use must be inspected and serviced more frequently.

Severe Use Definition

•Frequent immersion in mud, water or sand

•Racing or race-style high RPM use

•Prolonged low speed, heavy load operation

•Extended idle

•Short trip cold weather operation

Pay special attention to the oil level. A rise in oil level during cold weather can indicate contaminants collecting in the oil sump or crankcase. Change oil immediately if the oil level begins to rise. Monitor the oil level, and if it continues to rise, discontinue use and determine the cause or see your dealer.

91

Image 93

Polaris 550 EPS owner manual Periodic Maintenance Chart, Severe Use Definition

Contents

Sportsman X2 550 EPS Page Welcome Page Table of Contents Introduction European Vibration and Noise VIN Vehicle Identification Numbers Safety Training Safety Helmet Safe Riding Gear Equipment Modifications BootsEye Protection Gloves Safety Warnings Operating Without InstructionAge Restrictions Handling Gasoline Exposure to ExhaustFailure to Inspect Before Operating Protective Apparel Using Alcohol or DrugsCarrying a Passenger Carrying More Than One Passenger Operating on Pavement Carrying a Passenger Cargo BoxOperating on Public Roads Operating at Excessive Speeds Physical Control of the ATV Turning ImproperlyJumps and Stunts Improper Hill Climbing Descending Hills ImproperlyCrossing Hillsides Operating on Steep Hills Stalling While Climbing a Hill Operating on Slippery Terrain Operating in Unfamiliar TerrainOperating Improperly Reverse Improper Tire Maintenance Operating Over ObstaclesSkidding or Sliding Improper Cargo Loading Operating Through Deep Water Poor Visibility Operating on Frozen Bodies Water Physical Skills Operating a Damaged ATVHot Exhaust Systems Unauthorized Use of the ATV General Warning Safety Labels and Locations Reverse Override Warning/AWD Caution Age 16 Warning Passenger Must Always Passenger Safety//Discretionary Warning Tire Pressure/Load Warning Rack Warning, Front Clutch Cover WarningHitch Capacity Label Box Warning Switches Features and ControlsMode/Reverse Override Switch Engine Stop Switch Main Key Switch 4X4 SwitchHeadlight Switch Throttle Lever Brake Lever Master Cylinder/Brake Fluid Locking the Parking Brake Parking Brake Auxiliary Foot Brake Brake Fluid Level Electronic Power Steering EPS Automatic Transmission Gear SelectorBelt Life Fuel Tank Cap Extreme Use 30 AH Battery ADC 4X4 Mode 4X4 ModeAll Wheel Drive System 2X4 Mode Turf ModeEngaging Active Descent Control ADC System Engaging Active Descent ControlDisengaging Active Descent Control Seat Conversion Passenger Seat Backrest Adjustment Latch Passenger Front Box/Compartment Instrument Cluster Digital/Analog GaugeSpeedometer Lamp Indicates Condition Indicator Lamps Rider Information Center Features and Controls Display Units Standard/Metric Odometer Mode Programmable Service Interval Engine Error Codes Diagnostic Display Code Definitions Sportsman X2 550 EPS Diagnostic Codes EPS Models Only Break-In Period OperationEngine and Drivetrain Break-in PVT Break-in Clutches/Belt Remarks Pre-Ride Checklist Safe Operation Practices Trail Etiquette Know Your Riding Area/Tread Lightly Cold Weather Operation Starting the Engine Driving Procedures Turning the Vehicle Driving with a Passenger Operation Driving on Slippery Surfaces Driving Uphill Driving on a Sidehill Sidehilling Driving Downhill Turning Around on a Hill K-Turn Operation Driving Through Water Driving Over Obstacles Driving in Reverse Parking on an Incline Do not Travel Faster than the Recommended Speeds Hauling Cargo Never exceed 50 MPH 80 km/h while carrying a passenger Towing Loads Dumping Cargo Winch Guide Winch Safety Precautions Winch Guide Winch Guide Winch Operation YES no Winch Guide Winch Guide Winch Guide Winch Cable Care Shock Loading Winch Guide Winch Maintenance and Service Safety Emission Control Systems Maintenance Periodic Maintenance ChartSevere Use Definition Symbol Description Maintenance Chart Key Miles Fuel system 100 H 12 M Lubrication Guide Procedure Oil Recommendations Engine Oil Oil Level Oil and Filter Change Oil Filter Oil Check Transmission Oil Oil Change ADC Extreme Use Definition Front Gearcase Demand Drive Fluid Fluid Change Fluid Check Fluid Level Active Descent Control ADC Fluid Position the vehicle on a level Rear Gearcase Oil Power Steering Unit Cooling System Recovery Bottle Coolant Radiator Coolant Brakes Hand BrakeAuxiliary Foot Brake Toe Alignment Steering Assembly Side Panel/Footwell Removal Seat Removal Tire Tread Depth TiresFront Wheel Hub Tightening Wheel Removal Wheel Installation Wheel Nut Torque SpecificationsWheel Type Nut Type Nut Torque Air Filter Fuse Replacement Lights Headlight Lamp Replacement High Beam Adjustment Headlight Housing Replacement Low Beam Adjustment Taillight/Brakelight Lamp Replacement Lower Headlamp Replacement Spark Plugs Plug Condition Torque SpecificationSpark Plug Recommendations Spark Plug Inspection Wet Fouled Spark Plug Normal Spark Plug Vehicle Immersion Spark Arrester PVT System 127 When To Use Low Range and High Range PVT DryingCondition Range to Use Battery Removal Battery Battery Installation Battery Storage Battery Charging State Voltage Action Charge Time Throttle Cable Freeplay Throttle Body/Idle RPM 135 Handlebars Front and Rear Springs Camber and Caster Transporting the ATV Accessories Cleaning and Storage Washing the VehicleWashing Tips Polishing Tips Polishing the Vehicle Storage Tips Clean the ExteriorOil and Filter Fluid Levels Fog the Engine Battery StorageAir Filter / Air Box Inspect and Lubricate Drive Belt Wear/Burn Troubleshooting Engine Doesnt Turn Over Engine Turns Over, Fails to StartEngine Backfires Engine Runs Irregularly, Stalls or Misfires Engine Pings or Knocks Engine Overheating Engine Stops or Loses Power Part Number Description Polaris Products Sportsman X2 550 EPS Specifications N/R/P Clutching Limited Warranty Warranty Lubricants and Fluids Limitations of Warranties and Remedies 152 HOW to Obtain Warranty Service Exported Products A. EPA Emissions Limited Warranty 156 California Residents Maintenance LOG 159 Index Battery 161 162 163 9924657