Starting the Engine, Stopping the Engine, Braking | Polaris PMS 419

OPERATION

Starting the Engine

1.Position the vehicle on a level surface outdoors or in a well-venti- lated area.

2.Sit in the driver's seat and fasten the seat belt. Secure the cab nets.

3.Place the transmission in PARK.

4.Apply the brakes. Do not press the throttle pedal while starting the engine.

5.Turn the ignition key past the ON/RUN position to START. Engage the starter for a maximum of five seconds. Release the key when the engine starts.

6.If the engine does not start within five seconds, return the ignition switch to the OFF position and wait five seconds. Repeat steps 5 and 6 until the engine starts.

7.Vary the engine RPM slightly with the throttle to aid in warm up until the engine idles smoothly.

NOTICE: Operating the vehicle immediately after starting could cause engine damage. Allow the engine to warm up for several minutes before operating the vehicle.

Stopping the Engine

1.Release the throttle pedal completely and brake to a complete stop.

2.Place the transmission in PARK.

3.Turn the engine off.

Braking

1.Release the throttle pedal completely. (When the throttle pedal is released completely and engine speed slows to near idle, the vehicle has no engine braking.)

2.Press on the brake pedal evenly and firmly. Practice starting and stopping (using the brakes) until you're familiar with the controls.

54

Image 58

Polaris PMS 419 owner manual Starting the Engine, Stopping the Engine, Braking

Contents

Ranger RZR Ranger RZR S Ranger RZR Page Page Page Welcome Page Table of Contents Introduction Introduction Vehicle Identification Numbers Safety Equipment Modifications Safe Riding Gear Helmet Gloves BootsEye Protection Clothing Using Alcohol or Drugs Safety WarningsAccessories Operating Without Instruction Seat Belts Failure to Inspect Before OperatingProtective Apparel Cab Nets Passengers in the Cargo Box Carrying Passengers RZRCarrying Multiple Passengers RZR Operating on Pavement Turning Improperly Operating on Public RoadsOperating at Excessive Speeds Jumps and Stunts Descending Hills Improperly Physical Control of the VehicleImproper Hill Climbing Stalling While Climbing a Hill Crossing HillsidesOperating in Unfamiliar Terrain Operating Improperly in Reverse Improper Tire MaintenanceOperating on Slippery Terrain Skidding or Sliding Operating Over ObstaclesOperating Through Water Operating on Frozen Bodies of Water Improper Cargo LoadingOperating a Damaged Vehicle Exposure to Exhaust Handling GasolineRefueling Hot Exhaust Systems Safety Labels and Locations Cargo Box Warning Maximum Weight Capacity Tire Pressure/Cargo Overload Warning RZR Cab Frame/Seat Belt Warning Age Warning Shift CautionOverturn Warning Discretionary Warning RZR Never operate 7176607 Passenger Safety Warning RZR Passenger Must Always Rear Passenger Cab Frame Warn- ing RZR Rear Passenger Grab Bar Features and Controls Component Locations Cab Frame Steering Storage Compartment Wheel Trailer Receiver Hitch Bracket Seats Rear Service PanelSeat Adjustments Seat Removal Steering Wheel Passenger Hand Hold Hood Fuel Cap Cab Nets Seat Belts Seat Belt Inspection Electronic Power Steering EPS SwitchesAuxiliary Outlet Headlight Switch Ignition SwitchAll Wheel Drive AWD Switch Gear Selector Using Low Range and High RangeCondition Range to Use Brake Pedal Throttle Pedal All Wheel Drive AWD System Engaging AWD Instrument Cluster Mode ButtonSpeedometer Indicator Lamps Lamp Indicates Condition Rider Information Center RPM Features and Controls Mode Button Display Units Standard/Metric Clock Mode Hour Meter Mode Odometer ModeTrip Meter Mode Engine Temperature Mode Programmable Service Interval Diagnostic Display Mode Engine Error Codes Operation Vehicle Break-in Period Brake System Break-in Engine and Drivetrain Break-inPVT Break-in Clutches/Belt Pre-Ride Inspection Remarks Safe Operation Practices Stopping the Engine Starting the EngineBraking Know Your Riding Area/Tread Lightly Parking the VehicleTrail Etiquette New Operator Driving Procedures Operation Driving with Passengers Driving on Slippery Surfaces Driving Uphill Driving on a Sidehill Sidehilling Driving Downhill Driving Through Water Driving Over Obstacles Driving in Reverse Parking on an Incline Hauling Cargo Towing Loads Belt Life Emission Control Systems Periodic Maintenance Chart MaintenanceSevere Use Definition Maintenance Chart Key Remarks Engine breather Hours Lubrication Recommendations Lube Method RZR Engine Oil Oil Recommendations Maintenance Oil and Filter Change Maintenance Transfer Case GearcasesFluid Check Fluid Change Transmission Main Gearcase Transfer Case Drain Plug Main Gearcase Drain Rear Gearcase Demand Drive Unit Front Gearcase Rear Gearcase Spark Plugs Gearcase Specification ChartSpark Plug Gap/Torque Normal Plug Spark Plug Removal and ReplacementSpark Plug Condition Wet Fouled Plug Fuse Feature Supported Fuses Fuse Label Lift tabs Cover removed Operation Cooling SystemAdding or Changing Coolant Radiator and Cooling Fan Radiator Coolant Level Coolant Level Polaris Variable Transmission PVT System PVT Drying Filter Systems Air Filter Spark Arrestor Throttle Freeplay Throttle SystemThrottle Freeplay Inspection Throttle Freeplay Adjustment Throttle Body/Idle RPM Brakes Brake Fluid Steering Wheel Inspection Brake Inspection Suspension Settings RZR and RZR S Base Models Suspension Settings RZR S Premium Models and RZR Front/Rear Spring Preload Front/Rear Shock Compression Tires Axle and Wheel Nut Torque SpecificationsTire Tread Depth Wheel Installation Wheel Removal Headlight Lamp Replacement Lights Headlight High Beam Adjustment Vehicle Immersion Brake Lights Battery Battery Removal Battery Installation Battery Storage Battery Fluid Conventional Battery Battery Charging Conventional Battery Battery Charging Sealed Battery State Voltage Action Charge Time Washing the Vehicle Cleaning and StorageWashing Tips Polishing the Vehicle Polishing Tips Chrome Wheel Care if equipped Removing Corrosion Storage Tips Fog the Engine Battery MaintenanceInspect and Lubricate Storage Area/Covers Transporting the Vehicle Removal from Storage Specifications Ranger RZR / RZR S Clutching Ranger RZR 125 Polaris Products Part Number Description Troubleshooting Drive Belt Wear/Burn Engine Turns Over, Fails to Start Engine Doesnt Turn OverEngine Backfires Engine Pings or Knocks Engine Runs Irregularly, Stalls or Misfires Engine Stops or Loses Power Declaration of Conformity Applicable European Directives Test / Evaluation Methods Warranty Limited Warranty Limitations of Warranties and Remedies HOW to Obtain Warranty Service Lubricants How to Get Service Exported Vehicles 136 A. EPA Emissions Limited Warranty 138 Maintenance LOG 140 141 Index 143 144