Quadra-Fire 21M-ACC owner manual Millennium Wood Stove ACC, C. Glass Replacement

R

2100 Millennium Wood Stove (ACC)

	CAUTION
	Handle glass assembly with care.
Glass	When cleaning glass:
Assembly	• Avoid striking, scratching or
	slamming glass.

•Do NOT clean glass when hot.

•Do NOT use abrasive cleaners.

•Use a hard water deposit glass cleaner on white film.

•Use commerical oven cleaner on heavier deposits.

•Remove all residue of oven cleaner or will permanently stain glass on next firing.

•

Refer to maintenance instructions.

C. Glass Replacement

1. Ensure that the fire is out and the appliance is cool to the touch.

2.Protect a table or counter top with padding or towels. Protect your hands and wear gloves to prevent injury.

3.Remove the door with the broken glass by lifting the door up and off of the hinges.

4.Lay door face down on a table or counter making sure the handle hangs over the edge so the door lays flat, on a soft surface.

5.Remove the screws from each glass retainer and remove the glass. (If screws are difficult to remove, soak with penetrating oil first).

6.Center the glass with edges evenly overlapping the opening in the door, (i.e. same space top and bottom, left and right sides).

7.Replace the glass retainers. Be careful not to cross thread the screws.

8.Tighten each retainer just a few turns until each is secured. Check again for centering of glass in door frame. Continue to tighten each retainer alternately, a few turns at a time, until the glass is secure. DO NOT OVERTIGHTEN.

9.Replace the door on the appliance.

Quadra-Fire stoves are equipped with ceramic super heat- resistant glass, which can only be broken by impact or misuse. Do not slam stove door or impact the glass. When closing door, make sure that logs do not protrude against the glass. Inspect glass regularly. If you find a crack or break, immediately put the fire out and return the door to your dealer for replacement of glass before further use.

WARNING

Handle glass with care.

• Inspect the gasket to ensure it is

Glassundamaged.

Assembly

•Do NOT strike, slam or scratch glass.

•Do NOT operate appliance with glass & door assembly removed.

•Do NOT operate with glass cracked, broken or scratched.

WARNING

Fire Risk.

Injury Risk.

•Use only glass specified in manual.

•DO NOT REPLACE with any other material. Glass breakage will occur.

May 5, 2011 7039-131H Page 29