TABLE OF CONTENTS |
| |
SECTION 1: Before You Begin | 1 | |
1.1 Read This Manual | 1 | |
1.2 Questions, Comments or Suggestions | 1 | |
SECTION 2: Introduction | 2 | |
2.1 | About | 2 |
2.2 | About the Heater | 2 |
2.3 | Unpacking the Heater | 2 |
2.4 | Carton Contents of Heaters with Galvanized Venting .. | 3 |
2.5 | Carton Contents of Heaters with Cox Geelen Venting . 4 | |
2.6 | Available Accessories for Galvanized Vent | 5 |
2.7 | Available Accessories for Cox Geelen Vent | 6 |
2.8 | Components Identification | 7 |
2.9 | Technical Specifications | 8 |
2.10 Where Can the Heater Be Installed? | 9 | |
2.11 Where Can't the Heater Be Installed? | 9 | |
2.12 Installer's Responsibility | 9 | |
SECTION 3: Planning | 10 | |
3.1 | General | 10 |
3.2 | Gas Service Requirements | 10 |
3.3 | Electrical Service Requirements | 10 |
3.4 | Venting Requirements | 11 |
3.5 | 11 | |
SECTION 4: Installation | 13 | |
4.1 | Safety Equipment | 13 |
4.2 | Installation Tools | 13 |
4.3 | Installation Materials | 13 |
4.4 | Choose Location for Heater | 13 |
4.5 | General Venting Guidelines | 14 |
4.6 | Required Safe Distances from Combustibles | 15 |
4.7 | Hang the Heater | 17 |
4.8 | Remove Shipping Screw from Control Housing Door 17 | |
4.9 | Heater Assembly | 17 |
4.10 Typical Installation | 18 | |
4.11 Heater Orientation | 18 | |
4.12 Horizontal Installation | 18 | |
4.13 45° Tilted Installation | 19 | |
4.14 Grille Installation (for Select Models Only) | 20 | |
SECTION 5: Venting Installation | 21 | |
5.1 | General Venting Requirements | 21 |
5.2 | Install Galvanized Collar | 21 |
5.3 | Galvanized Horizontal Venting | 22 |
5.4 | Cox Geelen Horizontal Venting | 27 |
5.5 | Cox Geelen Vertical Venting | 29 |
SECTION 6: Electrical Service Installation | 31 | |
6.1 | System Requirements | 31 |
6.2 | Grounding | 31 |
6.3 | Important Notes | 31 |
6.4 | Thermostat Placement | 31 |
6.5 | Thermostat Installation | 31 |
SECTION 7: Gas Service Installation | 33 | |
7.1 Install Gas Supply Lines | 33 | |
SECTION 8: Operation | 34 | |
8.1 | Operating Instructions | 34 |
8.2 | To Turn Off Gas To Heater | 34 |
8.3 | Sequence of Operation | 34 |
8.4 | Testing | 34 |
SECTION 9: Troubleshooting | 36 | |
9.1 | General | 36 |
SECTION 10: Maintenance | 41 | |
10.1 | 41 | |
SECTION 11: Wiring Diagrams | 42 | |
11.1 Connection Diagram | 42 | |
11.2 Ladder Diagram | 43 | |
SECTION 12: Replacement Parts | 44 | |
12.1 Illustrated Parts List for Burner | 44 | |
12.2 lllustrated Parts List for Tube and Reflector | 46 | |
12.3 Replacement Parts List for Tube & Reflector | 46 | |
SECTION 13: The ROBERTS GORDON® CARIBE® LIMITED | ||
Warranty | 47 |
© 2005
All rights reserved. No part of this work covered by the copyrights herein may be reproduced or copied in any form or by any means - graphic, electronic, or mechanical, including photocopying, recording, taping or information storage and retrieval systems - without the written permission of
Printed in the U.S.A.