INSTALLATION INSTRUCTIONS
– Inverter Split System Air Conditioner –
COOL/DRY Model
This air conditioner uses the new refrigerant R410A. NOTE Refrigerant service valve size = 5/16"
Contents
|
|
| Page |
IMPORTANT! |
| ||
Please Read Before Starting | 2 | ||
1. | GENERAL | 3 | |
| Tools Required for Installation (not supplied) | ||
| Accessories Supplied with Unit |
| |
| Optional Copper Tubing Kit |
| |
| Type of Copper Tube and Insulation Material | ||
| Additional Materials Required for Installation | ||
2. | INSTALLATION SITE SELECTION | 4 | |
| Indoor Unit |
| |
| Outdoor Unit |
| |
3. | HOW TO INSTALL THE INDOOR UNIT | 12 | |
| Remove the Rear Panel from the Unit |
| |
| Make a Hole |
| |
| Install the Rear Panel on the Wall |
| |
| Removing and Installing the Grille |
| |
| Shape the Indoor Side Tubing |
| |
| Wiring Instructions |
| |
| Wire Size and Length |
| |
| Wiring Instructions for | ||
| Mounting |
| |
| Frame Fastening Method |
| |
| Drain Hose |
| |
4. | HOW TO INSTALL THE OUTDOOR UNIT | 22 | |
| Wiring Instructions for the Outdoor Unit |
| |
| Routing the Tubing and Wiring |
| |
5. | REFRIGERANT TUBING | 23 | |
| Use of the Flaring Method |
| |
| Flaring Procedure with a Flare Tool |
| |
| Caution before Connecting Tubes Tightly |
| |
| Connecting Tubing between Indoor and |
| |
|
| Outdoor Units |
|
| Insulation of Refrigerant Tubing |
| |
| Taping the Tubes |
| |
| Finishing the Installation |
| |
Model Combinations
Combine indoor and outdoor units only as listed below.
Indoor Unit | Outdoor Unit | ||
KS3082 |
|
| C3082 |
|
| ||
KS3682 |
|
| C3682 |
| |||
Power Source: |
| ||
60 Hz, |
| ||
Be sure to read the yellow instruction sheet attached to the outdoor unit for models using the new refrigerant R410A.
7.REMOTE CONTROL UNIT INSTALLATION
POSITION | 29 | |
Mounting on a Wall |
| |
8. ADDRESS SWITCH | 30 | |
Address Setting of the Remote |
| |
| Control Unit |
|
NOTE
The illustrations are based on the typical appearance of a standard model. Consequently, the shape may differ
6. AIR PURGING | 25 |
■Air Purging with a Vacuum Pump (for Test Run)
■Basic Functions of the Service Valves
■Pump Down
■Service Valve Connections
85264190499000 © SANYO 2010
from that of the air conditioner that you are installing.
SANYO North America Corporation | In Canada |
Commercial Solutions Division | SANYO Canada Inc. |
2055 Sanyo Ave., San Diego | 201 Creditview Road, Woodbridge |
CA 92154, U.S.A. | Ontario, L4L 9T1, Canada |
| W |
