Pentair Hot Tub manual For Your Safety Read Before Lighting, Lighting Instructions

Page 6

Operation (contd.)

5

MINIMAX® CH MILLIVOLT LIGHTING/OPERATION-NATURAL GAS & PROPANE

FOR YOUR SAFETY: READ BEFORE LIGHTING

WARNING

If you do not follow these instructions exactly, a fire or explosion may result causing personal injury, loss of life and property damage.

Since propane gas is heavier than air, escaping propane will accumulate and remain at ground level. Do not attempt to light the heater. If you suspect a propane leak, lighting the heater can result in a fire or explosion which can cause personal injury, death, and property damage.

A.This heater is equipped with a pilot which must be lighted manually. When lighting the pilot, follow these instructions exactly.

B.BEFORE LIGHTING smell all around the heater area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor.

WHAT TO DO IF YOU SMELL GAS

-Do not try to light any heater.

-Do not touch any electrical switch; do not use any phone in your building.

-Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.

-If you cannot reach your gas supplier, call the Fire Department.

C.Use only your hand to push in or turn the gas control knob. Never use tools. If the knob will not push in or turn by hand, don't try to repair it. Call a qualified service technician. Forced or attempted repair may result in a fire or explosion.

D.Do not use this heater if any part has been under water. Immediately call a qualified service technician to inspect the heater and to replace any part of the control system and any gas control which has been under water.

LIGHTING INSTRUCTIONS

1.STOP! Read the safety information above.

2.Set the thermostat to the lowest setting.

3.Turn off electric power to the heater.

4.Push in gas control knob slightly and turn clock-

wise to “OFF”.

Robertshaw Millivolt Gas Valve

Honeywell Millivolt Gas Valve

Figure 1.

Figure 2.

Gas control knobs shown in “OFF” position.

NOTE

Knob cannot be turned from “Pilot to “OFF”” unless knob is pushed in slightly. DO NOT FORCE.

5.Wait five (5) minutes to clear out any gas. If you then smell gas, STOP! Follow "B" in the safety informa- tion above. If you don't smell gas, go to the next step.

6.Push in gas control knob slightly and turn

counterclockwise to “Pilot”.

7.Push the control knob all the way and hold in. Immediately light the pilot with Presslite matchless ignition system by pressing the red igniter button (located at the panel next to the gas valve). Continue to hold the control knob in for about one (1) minute after the pilot is lit. Release knob and it will pop back up. Pilot should remain lit. If it goes out, repeat steps 4 through 7.

•If knob does not pop up when released, stop and immediately call your service technician or gas

supplier.

Figure 3.

 

•If the pilot will not stay lit after several tries, turn the gas control knob to “OFF” and call your service technician or gas supplier.

8.Turn knob on gas control

counterclockwise to “ON”.

9.Replace the control access door.

10.Set the thermostat to the

desired setting.

Figure 4. Pilot

TO TURN OFF GAS TO HEATER

1.Set the thermostat to lowest setting.

2.Turn off all electric power to the heater if service is to be performed.

3.Remove control access door.

4.Push in gas control knob slightly and turn clockwise to "OFF". Do not force.

5.Replace control access door.

Rev. E 11-5-07

P/N 472128

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Pentair Water Pool and Spa, Inc. All rights reserved For Your Safety Read Before Operating What to do if YOU Smell GASFor additional free copies of this manual call 800 Table of Contents Introduction Code RequirementsImportant Notices Operation Warranty InformationSafety Rules Product IdentificationFor Your Safety Read Before Lighting Lighting InstructionsTo Turn OFF GAS to Heater Dual Temperature Control System Operating ControlsEnergy Saving Tips MaintenanceMaintenance Instructions Spring and Fall OperationChemical Balance PH ChartPH Control Chart Pool and Spa WaterOutdoor installation stackless Installation InstructionsSpecifications Outdoor installation with vent kitPlumbing Connections PlumbingInsulating the High Limits When Reversing Heads on the MiniMax CH HeaterWater Connections Reversible Inlet/Outlet ConnectionGAS Line Installations GAS ConnectionsRegulated Manifold Pressure Test Ventilation Outdoor Installation onlyOutdoor Vent CAP Installation Stack Type Outdoor Vent KITFront Indoor Draft Hood Installation Stack Type Indoor Draft Hood KITAll opening sizes are minimum and unobstructed MiniMax CH Millivolt Wiring Diagram ElectricalTroubleshooting General Heater exchanger scaledHeater Short Cycling Rapid On and Off Operation Minimax CH Heater ALL Models MiniMax CH Parts List MiniMax CH Parts List, contd Rev. E MiniMax CH 150 IID Model Operating Instructions To Turn OFF GAS to ApplianceOperation Safety Lockout Indicator Light Description Thermostat Knob StopperTroubleshooting Controls Heat HeatTroubleshooting Controls Installation Transformer Wiring InstructionRegulated Manifold Pressure Test Electronic Ignition Wiring DiagramRemote Switch Dual Therm IID only Wire RemoteMinimax CH Heater 150 IID Model MiniMax CH Parts List 150 IID Model 150MiniMax CH Parts List 150 IID Model, contd Rev. E Pentair Water Pool and Spa, Inc. All rights reserved Chauffe Eau MiniMax CH QUE Faire EN CAS D’ODEUR DE GAZ ?Table des Matières Exigences Légales Consignes IMPORTANTES…Consignes DE Sécurité FonctionnementGarantie Fonctionnement suitePour Votre Sécurité Lire Attentivement Avant D’ALLUMER Consignes DE FonctionnementFemer L’ARRIVÉE DU GAZ Vers L’APPAREIL Fonctionnement Contrôles Commutateur Électrique Sélection du thermostatConsignes DE Maintenance Fonctionnement EN Automne ET AU PrintempsFonctionnement EN Hiver Échelle de pH Équilibre ChimiqueEAU DE Piscine ET DE Thalasso Tableau de contrôle du pHInstallation en extérieur sans cheminée Installation en extérieur avec kit de ventilationCaractéristiques Soupapes Installation Sous LA PiscinePlomberie Déviation ManuelleBranchement réversible entrée/sortie Raccords D’ARRIVÉE D’EAUIsoler LES Hautes Limites Inverser les Raccords d’Arrivée d’eauInstallations DE LA Conduite DE GAZ Raccord DE GAZTest PRÉ-RÉGLÉ DE Pression Multiple Exigences Pour LA Pression DU GAZ DU Minimax CHInstallation EN Extérieur Uniquement Côté Face Arrière Sommet Installation SUR DES Sols Combustibles Les exigences pour l’approvisionnement d’air ciSystème Électrique Organigramme DES Circuits À Millivoltmètre DU Minimax CHChauffe-eau à cycle court Fonctionnement on et OFF rapide Détection de pannes GénéralMettre en position on Débit d’eau insuffisantCHAUFFE-EAU Minimax CH Tout Modèle Liste des Pièces du MiniMax CH Liste des Pièces du MiniMax CH suite Sans IllustrationRemarques MiniMax CH 150 IID Model Consignes DE Fonctionnement Fermer L’ARRIVÉE DU GAZ Vers L’APPAREILFonctionnement Remarque Verrouillage de sécuritéDescription DES Voyants Lumineux Commutateur MARCHE/ARRÊT Sélecteur de températureDépannage Contrôles Pressostat PressDépannage Contrôles Suite Classement électrique Vérification DE LA Pression ’ADMISSION ContrôléeÉLECTRIQUE, Unités Électroniques IID Raccordement Électrique Du TransformateurIID Schéma de câblage du MiniMax CH Modèle 150 IIDCommande À Distance À Deux Fils Circuit DU ThermostatCHAUFFE-EAU Minimax CH Modèle 150 IID Description QTÉ Description QTÉ Remarques Conservez CES Consignes EN Lieu SÛR LEA Antes DE Operar POR SU Seguridad ¿QUÉ Hacer SI Huele a GAS?Contenido Introducción Requerimientos DE CódigosNotas Importantes Normas DE Seguridad OperaciónInformación DE Garantía Operación contdLEA Antes DE Encender POR SU Seguridad Instrucciones DE Encendido¿CÓMO Desconectar EL GAS DEL CALENTADOR? Operación Controles Interruptor DE Energia Selector del termostatoMantenimiento Operaciones Durante LA Primavera Y OtoñoOperaciones Durante Invierno Cuadro pH Balance QuímicoAgua DE Piscinas Y SPA Tabla 2. Cuadro de Control del pHInstalacion Externa sin chimenea Instrucciones de InstalaciónEspecificaciones Instalación Externa con kit de ventilaciónBY-PASS Manual Conexiones Para LA TuberíaTuberías VálvulasConexión intercambiable de entrada y salida Conexiones Para EL AguaAislamientodeloslímitesaltos Al Intercambiar los Cabezales del Calentador MiniMax CHConexiones Para GAS Instalaciones Lineales Para GASPrueba DE Presion DEL Colector Regulado Requerimientos Para LA Presión DE GAS Minimax CHNatural Propano KIT DE Ventilación Externa Tipo Chimenea VentilaciónSólo Instalación Externa ¡IMPORTANTEInstalación Interna sólo para Eeuu Instalación Para Protección Externa CanadaKIT DE Campana Lateral Interna Tipo Chimenea Instalación Interna DE LA Campana LateralDiagrama de cableado electrónico millivolt ElectrónicaLimpiar los filtros y coladores de la bomba Soluciónes para diferentes problemas GeneralCableado defectuoso Reemplazar o reparar Válvula de flujo defectuosa o no reguladaCalentador Minimax CH- Todos LOS Modelos Lista DE Partes DEL Minimax CH Lista DE Partes DEL Minimax CH, contd Notas MiniMax CH 150 IID Modelo Operación Instrucciones DE OperaciónCómo Desconectar EL GAS DEL Artefacto ¿Qué hacer cuando huele a gas?Cierre de seguridad Descripción DE Luces Indicadoras Regulación DEL TermostatoIndicador DE Defectos Controles Calor HeatIndicador DE Defectos Controles , Contd Prueba DE Presión Múltiple Regulada InstalaciónInstrucciones para el Cableado del Transformador 150 IID Redmv WHTPV/MV BlupvInterruptor Dual Remoto Termico IID Cables RemotosCalentador Minimax CH Modelo 150 IID Lista de partes del MiniMax CH Modelo 150 IID ART Descripcion CantCalentador Minimax CH Modelo 150 IID, contd ART Descripcion CantNotas Conserve Estas Instrucciones Pentair Water Pool and Spa, Inc. All rights reserved

Hot Tub specifications

Pentair has established itself as a prominent name in the hot tub industry, renowned for its commitment to innovation, quality, and user-friendly design. The Pentair Hot Tub brings together advanced features and cutting-edge technology, offering an unparalleled experience for relaxation and hydrotherapy.

One of the standout features of Pentair hot tubs is the emphasis on energy efficiency. Incorporating modern insulation techniques and energy-efficient pumps, these hot tubs minimize energy consumption while maximizing performance. This not only helps reduce utility bills but also benefits the environment, a priority for many eco-conscious consumers today.

The water filtration system in Pentair hot tubs is another notable characteristic. With state-of-the-art filtration technology, these hot tubs ensure crystal-clear water while requiring minimal maintenance. The system typically includes a combination of skimmers, cartridge filters, and ozonators, which work together to eliminate impurities and keep the water fresh, allowing users to spend more time enjoying their hot tub and less time on upkeep.

Comfort is paramount in Pentair hot tubs, which feature ergonomic seating and adjustable jets for a customized hydrotherapy experience. The strategically placed jets deliver targeted massage to key muscle groups, providing relief from stress and tension. Users can easily adjust the jet pressure to suit their preferences, making it suitable for everyone, from casual users to serious hydrotherapy aficionados.

Another significant technology integrated into the design of Pentair hot tubs is the advanced control system. This allows users to manage temperature, jet settings, lighting, and even integrated entertainment features such as Bluetooth audio systems via a user-friendly interface. With smart technology, users can also control their hot tub remotely, offering convenience and enhancing the overall user experience.

Durability and aesthetic appeal are also essential characteristics of Pentair hot tubs. Constructed with high-quality materials that resist fading, cracking, and warping, these hot tubs are designed to withstand various weather conditions while maintaining their beautiful appearance. The sleek design options and customizable colors allow users to choose a hot tub that complements their outdoor space beautifully.

In conclusion, Pentair hot tubs stand out for their combination of energy efficiency, advanced filtration systems, ergonomic comfort, smart technology, and durability, making them an excellent choice for anyone looking to invest in a quality hot tub experience. Whether for relaxation or therapeutic needs, the Pentair hot tub is designed to provide an exceptional outdoor oasis.
Top Page Image Contents