Generac 004373-1, 004626-0 owner manual Battery 12VDC 90-AH 27F Optional, Hold Down Battery

Page 51

Section 7 — Exploded Views and Parts Lists

(Model Nos. 004373-1 & 004626-0) Guardian Liquid-cooled 40 kW Generators

Battery – Drawing No. A6708-F

	TO STARTER
11	SOLENOID	6
11		6

	12	13	5	9
			5	9
				RED
				RED
				3
14				BLACK
				BLACK
TO ENGINE BLOCK				2
TO ENGINE BLOCK
	9			8
				8
	4

			7
ITEM	PART NO.	QTY. DESCRIPTION
2	058665	1	BATTERY 12VDC 90-AH 27F (OPTIONAL)
3	061902	1	HOLD DOWN BATTERY
4	059473	1	HOLD DOWN BATTERY
5	038805H	1	CABLE BATTERY BLACK #1 X 23.00
6	038804N	1	CABLE BATTERY RED #1 X 15.00
	038804T	1	CABLE BATTERY RED #1 X 31.00 (GEAR BOX-NON-GUARDIAN UNITS)
7	0A4010	2	SCREW HHC M8-1.25 X 60 FT G8.8
8	052858	2	NUT LOCK FLANGE M8-1.25
9	049820	2	NUT LOCK HEX M8-1.25 (NYLON INSERT)
11	023152	1	SCREW HHC 3/8-16 X 3/4 G5
12	022131	1	WASHER FLAT M10-3/8 ZINC
13	025507	1	WASHER SHAKEPROOF EXT 7/16 STL
14	022237	1	WASHER LOCK 3/8

Generac® Power Systems, Inc. 49

Image 51

Contents Power SYSTEMS, INC Authorized Dealer Location IntroductionSection Installation Drawings 56-57 Warranty Back Cover Safety Rules General InformationInstallation MaintenanceGeneral Hazards Electrical Hazards Automatic System Operation UNPACKING/INSPECTIONGenerator Generator AC Connection SystemsSpecifications Main Circuit BreakerEngine Protective Devices Conversion to LP GAS Vapor Fuel Requirements RecommendationsGenerator and Load Compatibility EngineCoolant Emissions Control SystemAIR Fuel Ratio Controller Other Published Standards Standby Generator InstallationBasic Standby Electric System Nfpa StandardsEmergency Circuit Isolation Method Transfer Switch Start Signal ConnectionsGTS Type Switch Pre-Packaged Type SwitchBattery Installation Preparation Before START-UPVented Batteries Prior to Initial START-UP Using the AUTO/OFF/MANUAL Switch Sequence of Automatic Operation OFF PositionManual Position Automatic Transfer OperationChecking the Engine OIL Level Weekly Exercise CycleEngine Oil Recommendations Oil and Filter Change ProcedureChanging the Engine AIR Cleaner Changing the Engine OIL and FilterSpark Plugs Battery MaintenanceDC Fuse Miscellaneous MaintenanceCleaning the Generator Overload Protection for Engine DC Electrical SystemOUT of Service Procedure Removal From ServiceReturn To Service SYSTEM/COMPONENT Procedure Frequency Service ScheduleProblem Cause Correction Troubleshooting GuideElectrical Data Section Power Systems, Inc Generac Power Systems, Inc Electrical Data Electrical Data Electrical Data Wiring Diagram DPE RED Brush UnitsPanel Face Part of Control Panel Wire Harness Switch Rocker Dpst 125V SPDSwitch TOG Dpdt 15/10 SP Switch Selector 6A AMP/VGenerators Cover Plate Egov CONTROLLER, B-C #DPG-2103Screen Cover Plate AVRCover Conn Housing Assembly Motor StepperConnector Interface Assembly Housing Governor ConnectDIRECT-COUPLED BASE, Mounting ASSEMBLY, 4.3LAssembly Groundwire 10/3/8 Plug Button 3 DIA4640 31 33 Pulley Tensioner Switch OIL PressureDC Alternator Assembly Engine 4.3L GMExploded Views and Parts Lists Connector C/C Vent Retainer Plug WiresRetainer Spark Plug Wires Wires Spark Plug 4.3LAdd item #42 vinyl trim as shown Carrier Rear Bearing FAN Assembly 390 SAE DDAssembly Brush & Shunt Assembly Scroll 390 SAEDuct Front Panel Assembly Cover AccessDuct Bottom Shakeproof INT M6 SSVenturi 16 DIA 35KW Tank Coolant RecoveryBracket Coolant Recovery Tank Radiator 14 FIN/INCHGasket Carburetor Adaptor Plate AIR Cleanr BottomPlate AIR Cleaner TOP Gasket AIR CleanerActuator Throttle 42MM Mixer only Natural GASNPT X Hose 1 in ID LP GASHose 1IN ID LP GAS Support Solenoid NAT GASNipple TOE 3/4 NPT X Nipple Pipe 3/4NPTX4.5 BLK IRNRegulator N/G R600S LUG Rngtng INSDECAL,INLET Pressure HOSE, Preformed Block Heater Hose Connection TEEHEATER, Engine 1800W HEATER, Engine 2000WCable Battery RED #1 X Battery 12VDC 90-AH 27F OptionalHold Down Battery Cable Battery Black #1 X11 12 Transformer 200A to 5A 5VA Cover Lower Connection BOXBushing Snap SB-2.5-31 Relay Solenoid 12VDC PNL MNTExploded Views and Parts Lists Shield Heat Crossover 4.3L Tube Straight a GroupMuffler Catalyst 4.3L Mounting Band A-GRP CatalystClamp Band Muffler Muffler 2-1/2 INLET/OUTLETGuardian Liquid-cooled 40 kW Generators Installation Drawings 12V Battery see Note Lifting EYE Places This Warranty Shall not Apply to the Following Warranty Schedule

Section 7 — Exploded Views and Parts Lists

TO STARTER

SOLENOID

RED

BLACK

TO ENGINE BLOCK

QTY. DESCRIPTION

BATTERY 12VDC 90-AH 27F (OPTIONAL)

HOLD DOWN BATTERY

CABLE BATTERY BLACK #1 X 23.00

CABLE BATTERY RED #1 X 15.00

CABLE BATTERY RED #1 X 31.00 (GEAR BOX-NON-GUARDIAN UNITS)

NUT LOCK FLANGE M8-1.25

NUT LOCK HEX M8-1.25 (NYLON INSERT)

WASHER FLAT M10-3/8 ZINC

WASHER SHAKEPROOF EXT 7/16 STL

WASHER LOCK 3/8

Generac® Power Systems, Inc. 49