Meco 6623S8E641 manual Cooking On the Gas Grill, Grill Cooking Direct Method

Page 30

30

Cooking On the Gas Grill

!WARNING

To reduce the risk of serious bodily injury or death from fire, explosion or burn hazard:

Never use charcoal or lighter fluid in your gas grill. Keep this outdoor cooking appliance clear and free from combustible materials, gasoline, and other flammable vapors and liquids.

Keep any electrical supply cord and regulator hose away from any heated surfaces.

Make sure there are no gas leaks or obstructions to the flow of combustion and ventilation air before each use.

Keep the ventilation openings of the LP Gas Cylinder enclosure free and clear from debris.

Always open the Hood before lighting the LP gas grill.

Do not attempt to extinguish a grease fire with water or other liquids. Have a BC fire extinguisher accessible. Never douse or spray the grill or cooking surfaces with water when hot. Burns from grease or water splatters could occur.

If your gas grill catches on fire:

-If the fire is in the grill portion and you can safely reach the Control Knobs on the Control Panel, then turn them to the “Off” position.

-If the fire is in one of the hoses, and you can safely reach the LP Gas Cylinder valve, then shut the valve off.

-If the fire involves the LP Gas Cylinder, leave it alone, evacuate the area, and call the Fire Department.

-If there is any type of fire that threatens either personal safety or endangers property, call the Fire Depart- ment.

Do not use the grill without the Drip Cup in place. Check the Drip Cup for build-up. Empty excess grease to avoid a grease fire in the Drip Cup.

If you notice grease or other hot material dripping from the grill onto the valve, hose, or regulator, turn off the gas supply immediately. After the grill has cooled, determine the cause and correct it. After cleaning the valve, hose, and regulator assembly, perform a leak test before continuing use. See “Performing a Leak Test.”

Do not operate a gas grill if you have knowledge of or suspect a gas leak.

Do not wear loose clothing (example: hanging shirt tails, clothing with frills, etc.) around a gas grill while in use or hot.

Do not lean your body over the gas grill when lighting it or while it is in use or hot.

Do not touch hot surfaces. Use heat-resistant gloves, long-handled tongs, or cooking mitts at all times, since the grill will become very hot. Open the Hood carefully when cooking to avoid burns from the hot air and steam trapped inside.

Do not allow children to operate or play near a gas grill. Keep children, animals and bystanders out of the grill area. Do not leave grill unattended.

Do not move an LP gas grill when in use or hot.

When grill is not in use, turn off all grill Control Knobs, LP Gas Cylinder valve, and disconnect the

LP Gas Cylinder.

Grill Cooking (Direct Method)

!WARNING

To reduce the risk of serious bodily injury or death from fire or explosion:

Do not cover more than half (50%) the cooking area if using griddle plates. Full coverage of cooking area will cause overheating below the plates.

Always make sure the Foil Pan, Grease Pan, and Bottom Panel are empty and are properly installed under the Bowl before each cooking.

Do not leave any utensils or cookware on a hot Cooking Grid.

Image 30
Contents 6623S8E6416623S8Y641 For Outdoor Household Use Only. Not for Commercial UseTools Required for Assembly Carbon Monoxide HazardContents Preparation for AssemblyParts Illustration Model 6623S8E641 Parts List- Model 6623S8E641 Key Description QuantityDescription Quantity Parts Illustration Model 6623S8Y641 Parts List- Model 6623S8Y641 Assembly Instructions Step Front Leg Frame AssemblyStep Rear Leg Frame Assembly Step Rear Crossbrace Assembly Step Cart Frame Assembly Step Side Table Support AssemblyStep Side Tables to Cart Frame Assembly Step Heat Shield AssemblyStep Shroud Assembly Step Manifold Assembly Step Shroud to Cart AssemblyStep Wheel Assembly Model 6623S8Y641 Wheel Assembly Model 6623S8E641Step Cylinder Blocking Wires Assembly Step Drip Cup Wire Assembly Step Main Burner AssemblyStep Bowl and Cylinder Heat Shield Assembly Brace Wire AttachmentStep Side Burner Electrode Assembly Step Side Burner AssemblyStep Main Burner Electrode Assembly Electrode Wire Plug AssemblyThermometer Assembly Model 6623S8Y641 only Step Hood/Hinge AssemblyStep Hood Handle Step Flavor Activator / Warming Rack Assembly Step Cooking Grid / Control Knob AssemblyStep Drip Cup Assembly Cylinder Retainer Wire AssemblyStep Battery in Igniter Installation Connecting/Disconnecting the Gas Using GasLP Gas Cylinder Connecting LP Gas Cylinder LP Hose and RegulatorSelecting a Location Before Using Your LP Gas GrillInstallation Codes Performing a Leak TestHow to Perform a Leak Test First Time USE and as required Lighting the Grill Using the Pulse-Spark Ignitor Check The FlameManual Lighting of the Grill on Manually Lighting the Grill Lighting the Side Burner Manually Lighting the Side BurnerManually Lighting the Side Burner Cooking On the Gas Grill Grill Cooking Direct MethodRoasting Indirect Method Direct Cooking on the GridsIndirect Cooking Roasting Warming Rack End of Cooking SessionCare and Maintenance Cleaning the GrillHow to Clean the Burners 16 gap Storage Troubleshooting EmergenciesClean the Burners. See How to Clean Burners in Care MaintenanceSee How to Clean Burners in Care and Maintenance Important Notice Limited Warranty Meco Corporation Limited Warranty