RedMax EDG2300R manual MA1 MA2, Daily Inspection, Inspection Every 25 Hours, MA3, MA4 MA5

Page 34

MA1

MA2

English

8. Maintenance

WARNING

Before cleaning, inspecting or repairing your unit, make sure that engine has stopped and is cool. Disconnect the spark plug terminal to avoid accidental engine starts.

DAILY INSPECTION

Remove grass or dust, from the entire body.

Check that all nuts and screws are securely tightened, and no parts are missing.

Check for leakage of fuel.

INSPECTION EVERY 25 HOURS

Remove the air cleaner element from the carburetor air intake cover and wash in warm, soapy water. Dry completely before installing. (MA2)

MA3

.024 ~ .028 in (0.6~0.7mm)

MA4

MA5

(1)

Check and clean the spark plug. Adjust the electrode gap to .024~.028in (0.6~0.7mm) if necessary. (MA3)

Replacement plug: NGK BPMR7A

INSPECTION EVERY 50 HOURS Gear case

• Apply a good quality lithium based grease through the grease fittIng. Lubrication should be applied at 50 hour Intervals and more frequent at heavy use. (MA4)

INSPECTION EVERY 100 HOURS

The muffler is equipped with a spark arrester to prevent red hot carbon from flying out of the exhaust outlet. In the State of California it is required by law (Section 4442 of the California Public Resources Code) to equip a spark arrester when a gas powered tool is used in any forest covered, brush covered, or grass covered unimproved land. (MA5)

(1) Spark arrester

34

Image 34
Contents EDG2300R Contents Tables des matieres Contenido Differents Types D’AVERTISSEMENT DE CE Mode D’EMPLOIAdvertencias Contenidas EN EL Manual Parts location SpecificationsEDG2300R Fiche technique Emplacement des pieces Situación de las piezasEspecificaciohes Emission Control Symbols on the machinePosition Important Engine InformationControl DE Emisiones EmplacementPosición Information Importante Concernant LE MoteurFor safe operation Consignes de securite Instrucciones de seguridad Work Gear and Clothing Avertissement Concernant Manipulation DE Carburant Consignes de securite Instrucciones de seguridadEquipement ET Vêtements DE Travail Equipo Y Prendas DE TrabajoThings to Check Before Using Your Portable GAS Drill Things to Check Before Starting UP the EngineVerifications a Effectuer Avant DE Demarrer LE Moteur Avoid Noise Problem Evitar Problemas DE Ruido Eviter LES Nuisances SonoresPortable GAS Drill Consignes de securite Instrucciones de seguridad Front grip Chuck unit Set upSE1 SE2 SE3 Chuck handle Selection of a Suitable BitLevier du mandrin Sélection d’un trépan approprié Assemblage MontajeAgarradera Levier Palanquita del portabrocaFuel When using Zenoah genuine oilRecommended Mixing Ratio Gasoline 50OIL Lors de l’utilisation de la véritable huile Zenoah Rapport DE Melange Recommande Essence 50 HuileCarburant Combustible Proporción DE LA Mezcla Recomendada Gasolina 50 AceiteFueling the Unit HOW to MIX FuelFor Your Engine LIFE, Avoid Eviter Pour Prolonger LA Duree DE VIE DU Moteur Comment Obtenir UN BON Melange Como Mezclar EL CombustibleRemplissage DU Reservoir Abastecimiento DE LA UnidadFuel Aceite Para USO EN Motores DE 4-TIEMPOS Operation Fonctionnement Uso Stopping Engine How to operate Reverse control OP8OP5 OP6 OP7 OP8 RUN Stop Boring Operation OP6, OP7Marche Comment opérer la commande inverseFonctionnement Uso Levier Cómo operar el control de ReversiónWhen Install or Loosen the Chuck More Securely OP10,11 Adjustment of Idling SpeedIdle adjustment screw OP9 OP10 OP11Tornillo de ajuste de ralentí Vis de réglage du ralentiClé de 19 mm Levier de verrouillage Llave fija de 19 mm Palanca de bloqueoMaintenance Maintenance ChartTableau D’ENTRETIEN EntretienMantenimiento Tabla DE MantenimientoInspection Every 25 Hours MA1 MA2Daily Inspection MA3Entretien Mantenimiento Cleaning the cylinder fins StorageNettoyage des ailettes du cylindre Rangement AlmacenamientoLimpieza de las aletas del cilindro 10. Guía de localización y solución de problemas Troubleshooting guideGuide de localisation des pannes EDG2300R NotaParts list Gear Case a Engine Unit EDG2300R S/N 60000101 and up Qty Key# Part Number Description Limited Warranty RedMax Garantie limitée Garantía Limitada Page Komatsu Zenoah America INC