Desa VDCFTNB installation manual Thermostat Models

Page 37

PARTS LIST

THERMOSTAT MODELS

This list contains replaceable parts used in your ﬁreplace. When ordering parts, follow the instructions listed under Replacement Parts on page 42 of this manual.

KEY	PART NUMBERS
NO.	VDCFTPB	VDCFTNB	DESCRIPTION	QTY
1	111069-01	111069-01	Dual Burner	1
2	099056-29	099056-34	Injector	1
3	104424-04	104424-04	Outlet Tube	1
4	111124-01	111124-01	Burner Retainer Spring	1
5	107486-01	107485-01	ODS Pilot	1
6	099387-09	099387-09	Pilot Tube	1
7	098249-01	098249-01	ODS Nut	2
8	M11084-38	M11084-38	Screw, HWH AB 8-18 x .38	2
9	M11084-26	M11084-26	Screw, HWH AB 10-16 x .38	10
10	**	**	Chamber Floor	1
11	097809-02	097809-02	Male Fitting	1
12	098867-10	098867-14	Gas Regulator	1
13	108628-02	108628-02	Inlet Tube	1
14	102394-02	102394-02	Control Bracket	1
15	098522-13	098522-12	Thermostat Gas Valve	1
16	101381-01	101381-01	Valve Cover with Piezo	1
17	101628-03	101628-03	Flexible Connector	1
18	099211-01	099211-01	Screw, HWH AB 10-16 x 2.50	2
19	098544-01	098544-01	Thermobulb Clip	1
20	098271-10	098271-10	Ignitor Cable	1
21	113342-01	113342-01	Log Set	1

		PARTS AVAILABLE — NOT SHOWN

	901056-01	901056-01	Brass Flare Adapter Fitting	1
	103470-01	103470-01	Hardware Pack	1
	100563-01	100563-01	Warning Plate	1
	101054-01	101054-01	Lighting Instruction Plate	1

** Not a ﬁeld replacement part

116526-01A

www.desatech.com

37

Image 37

Contents What to do if YOU Smell GAS Shown with Optional Cabinet Mantel/Hearth Base AccessoryTable of Contents Safety Information Safety Information Product Identification Product FeaturesLocal Codes UnpackingSheet Metal Screws Hood Louver Firebox Top Hood AssemblyTools Required Phillips screwdriver Shoulder Screw ScreenProviding Adequate Ventilation AIR for Combustion VentilationDetermining FRESH-AIR Flow for Fireplace Location Ventilation Air From Inside Building Ventilation AIRVentilation Air From Outdoors Check GAS Type InstallationFireplace Clearances Installation ItemsMinimum Clearance to Combustible Materials TopActual Framing Height BUILT-IN Fireplace InstallationFront Width DepthMantel Shelf Optional Mantel InstallationSide of Firebox Top Louver Bottom LouverInstalling Optional Blower Accessory GA3450TA Switch Power Cord Installing Blower AccessoryPlate Remote Wire Blower Harness Bracket Lower Louver Door SwitchExtension Cord For Built-In InstallationBlower Bracket Connecting to GAS Supply Installation Items Needed Connecting Equipment Shutoff Valve to Heater ControlChecking GAS Connections Equipment Shutoff Valve Propane/LP Supply Tank Pressure Testing Fireplace Gas ConnectionsEquipment Open Shutoff Valve Closed Gas Regulator or Gas Control Valve EquipmentInstalling Receiver Optional Wireless HAND-HELD Remote Control AccessoriesReceiver Volt Terminal Battery Wires Battery Clip Installing 9-Volt Battery in Hand-Held Remote Control UnitFeed wires through rectangular slots Control Valve To Wall Thermostat or Switch Or SwitchInstall the base onto the wall with the pro- vided screws Remove jumper wire from control valve see ,For Your Safety Read Before Lighting Installing LOG SET and ScreenOperating Fireplace Lighting InstructionsTo Turn OFF GAS To Appliance Manual Lighting ProcedureThermostat Control Operation Shutting Off FireplaceAUTO/OFF/ON Switch REMOTE-READY Models For Your Safety Read Before LightingOperating Blower Pilot Ignitor Burner Electrode Piezo Flame Control Ignitor Adjustment Knob ButtonPilot Burner Ignitor Electrode Optional HAND-HELD Remote Operation Manual ModeThermostat Series Model HRC200 ON/OFF Series Model HRC100Optional GWMT1 Wall Mounted Thermostat Optional GWMS2 Wall Mounted SwitchInspecting Burners Cleaning MaintenanceCabinet LOG SETAir Passageways ExteriorObserved Problem Possible Cause Remedy TroubleshootingBurner oriﬁce is clogged Burner oriﬁce is clogged Clean burner see CleaningMote-Ready Models Only Models OnlyMote-Ready Models Only Power is low When heated, vapors fromSlight smoke or odor during Nance,Gas leak. See Warning Thermostat Models SpecificationsRemote-Ready Models Firebox Models VDC Illustrated Parts BreakdownParts List Thermostat Models Vdcftpb and Vdcftnb Thermostat Models REMOTE-READY Models Vdcfrnb and Vdcfrpb KEY Part Numbers Vdcfrpb Vdcfrnb Description QTY Equipment Shutoff Valve GA5010 AccessoriesPerimeter Trim KIT GA6095 THERMOSTAT-CONTROLLED Blower KIT GA3450TInformation Video Receiver and HAND-HELD Remote Control KIT HRC100 SeriesFor all models. Creates the sound of a real burn- ing ﬁre Service Hints Replacement PartsTechnical Service Parts Under Warranty116526-01A Keep this Warranty Warranty InformationLimited Warranty VENT-FREE Compact Classic Hearth