Invacare HMV Highly 300, HMV Highly 400 manual REMOVING/INSTALLING the Drive Wheels

Page 46

SECTION 11—WHEELS AND CASTERS

DETAIL “A” - 300

Keystock

WARNING:

PINCH POINT

	Cutout
Drive	Washer	Scooter Frame
Drive		Scooter Frame
Shaft	Hex Nut
	Hex Nut
		Drive Wheel
		DETAIL “B” - 400
	Swingarm

Scooter Frame

Keystock

Washer

Hex Nut

Drive Shaft

Drive Wheel

FIGURE 11.1 - REMOVING/INSTALLING THE DRIVE WHEELS

300 and 400

46

Part No. 1118395

Image 46

Contents HMVHighly Maneuverable Vehicle 300 Table of Contents Arms Tiller AdjustmentSeat Rear ShroudBatteries Scooter AccessoriesTransporting Register Your Product Register Your ProductProduct Registration Form Fold here Cut Along Line TIE-DOWN Restraints and Seat Restraints Special NotesSeat Positioning Strap Typical Product Parameters 300 400Label Locations Front Frame Assembly General Guidelines Repair or Service InformationOperation Information General Guidelines Tire Pressure ElectricalRain Test Weight TrainingBatteries Grounding InstructionsWeight Limitation EMI Information EMI InformationEMI Information Percentage of Weight Distribution SAFETY/HANDLING of Powered ScootersStability and Balance Stairways EscalatorsSafety Inspection Checklists Safety InspectionINSPECT/ADJUST Initially INSPECT/ADJUST Monthly INSPECT/ADJUST WeeklyINSPECT/ADJUST Every SIX 6 Months INSPECT/ADJUST Periodically Suggested Maintenance Procedures Maintenance and TroubleshootingLubrication Points Troubleshooting Symptom Probable Cause SolutionOperation of the Powered Scooter Control PanelNumber Fault Impact on Control PanelOperation of the Powered Scooter Number Fault Impact on Control Panel Horn and Throttle Control LeverOperating the Scooter Brake Release Lever Resetting the Circuit Breaker Brake Release LeverReplacing the Fuse Replacing the FuseSeat REMOVING/INSTALLING the SeatInstalling RemovingREMOVING/INSTALLING the Seat Post REMOVING/INSTALLING the Seat PostAdjusting Seat Height Adjusting Seat DepthSeat Swivel Adjustment Adjusting Seat DepthREMOVING/INSTALLING Seat Positioning Strap 90 Seat Swivel AdjustmentREMOVING/INSTALLING Seat Positioning Strap Adjusting ARM Width REMOVING/INSTALLING/ADJUSTING ArmsREMOVING/INSTALLING ArmsAdjusting ARM Angle Adjusting ARM HeightAdjusting ARM Height Replacing Armrest PadsTiller Adjustment Adjusting the Tiller AngleREMOVING/INSTALLING the Rear Shroud Rear ShroudREMOVING/INSTALLING the Drive Wheels Wheels and CastersREMOVING/INSTALLING the Drive Wheels REMOVING/INSTALLING the Front Wheel REMOVING/INSTALLING the Front WheelREMOVING/INSTALLING the Caster Assemblies REMOVING/INSTALLING the Caster AssembliesBatteries Recommended Battery Type REMOVING/INSTALLING the Batteries onRemoving REMOVING/INSTALLING the Batteries on REMOVING/INSTALLING the Batteries on Built-in Lifting Straps CONNECTING/DISCONNECTING the Battery Cables on ConnectingDisconnecting CONNECTING/DISCONNECTING the Battery Cables on ON-BOARD Battery Charger Charging the BatteriesBattery Charger Operation Charger Indicator Light on Tiller Charging Indicator StatusDisassembling TransportingTransporting the Scooter Assembling400 Transporting Right Scooter Accessories REMOVING/INSTALLING the Front BasketINSTALLING/REMOVING the CRUTCH/CANE Holder INSTALLING/REMOVING the CRUTCH/CANE HolderINSTALLING/REMOVING/USING the Walker Holder INSTALLING/REMOVING the Safety FlagInstallation Warnings INSTALLING/REMOVING the Walker Holder Using the Walker HolderINSTALLING/REMOVING the Rear Mounted Basket INSTALLING/REMOVING the Rear Mounted Basket300 300 Limited Warranty Limited WarrantyUSA