Grizzly G9249 owner manual Using the 4-Jaw Chuck, To mount a workpiece on the 4-jaw chuck

Page 27

5.Rotate the chuck key clockwise until you see the tip of the scroll-gear lead thread just begin to enter the jaw guide, as shown in

Figure 27.

Scroll-Gear

Lead Thread

Figure 27. Installing jaw into the 3-jaw chuck.

6.Position the jaw with the beveled edge point- ing to the center of the chuck, then insert the jaw into the jaw guide and hold it against the scroll-gear lead thread.

7.While firmly holding the jaw in place, rotate the chuck key clockwise one turn to engage the jaw with the scroll-gear threads.

Note: Pull on the jaw to make sure it is engaged with the scroll-gear.

8.Repeat Steps 6–7with the remaining jaws.

—If installed correctly, the three jaws will con- verge together at the center of the chuck.

—If the jaws do not come together, repeat this procedure until they do.

Using the 4-Jaw Chuck

The 4-jaw chuck features independently adjust- able hardened steel jaws to hold non-cylindrical or off-center workpieces. Each jaw can be removed from the chuck body and reversed for a wide range of work holding versatility.

Tools Needed

Qty

Chuck Key

1

G9249  12" x 37" Belt Drive Gap Bed Lathe

To mount a workpiece on the 4-jaw chuck:

1.DISCONNECT LATHE FROM POWER!

2.Use a piece of wood to protect the bedways.

3.Use the chuck key to open each jaw until the workpiece can lie flat against the chuck face.

4.With assistance to hold the workpiece in place, tighten each jaw in small increments. After adjusting the first jaw, continue tight- ening in opposing sequence, as shown in Figure 28, until the workpiece is firmly secure in the desired position.

&(

m

)'

Figure 28. 4-jaw tightening sequence.

5.Make fine adjustments by using a test indica- tor and adjusting the jaws until the workpiece is precisely aligned (see Figure 29).

Figure 29. Example of using a test indicator to

align a workpiece in a 4-jaw chuck.

-25-

Image 27
Contents Model G9249 Ss ,EAD from Leadbased PAINTS Table of Contents Introduction Foreword Functional OverviewContact Info Identification Machine Data Sheet Tailstock Info Other Specifications  !,7!93 53%3 %!2.2 02/4%#4/ %. /0%2!4.! -!#.%29  !,7!93 53% !.3 !002/6%$$ 3!&%49 ,!33%33 7%. /0%2!4 !,7!93 ,/#+ -/,% !3%3 & 53%$ % %&/2% /0%2!4. -!#.%29#  53%3!!2/5.$%$ %84%.3/..#/2$ 2!4%$4&/2/4%-!#.%!-0%2!%2 53%3 2%#/--%.$%$- !##%33/2%3  -!.9 -!#.%3 #!. %*%#4 7/2+0%#%3 4/7!2$ /0%2!4/2Additional Safety Instructions For Metal Lathes 220V Operation Circuit RequirementsUnpacking SetupSetup Safety Items Needed for SetupBox 1 Inventory Figure Qty InventoryBox 2 Inventory Figure Qty Left Cabinet Stand Clean UpFloor Load Lathe Assembly PlacementPlacement Location Site ConsiderationsLoosening the carriage lock bolt Using Machine Mounts Mounting to Shop FloorBolting to Concrete Floors Lubrication subsection on Check Gearbox OilTest Run To test run the machineMERGENCYG3TOP Utton Recommended Adjustments Factory adjustments that should be verifiedSpindle Break-In Headstock Controls Operation SafetyOperations Basic ControlsTailstock Controls Carriage ControlsChuck & Faceplate Mounting/Removal Tools Needed QtyTo remove a chuck or faceplate Mounting a Chuck or Faceplate Mounting a WorkpieceUsing the 3-Jaw Chuck To remove and install the jawsTo mount a workpiece in the 3-jaw chuck To mount a workpiece on the 4-jaw chuck Using the 4-Jaw ChuckTo mount a workpiece on the faceplate Using the FaceplateInstalling a Sleeve and Center into the Spindle CentersInstalling a Tapered Tool into the Quill TailstockRemoving a Sleeve and Center from the Spindle To align the tailstock with the headstock Offsetting TailstockTo set up the tailstock to cut a shallow taper Aligning TailstockStep To set up the tailstock for drilling Drilling with TailstockTo remove a tapered drill arbor or drill bit Steady Rest To install and use the steady restFollow Rest Cross SlideHandwheel Dial Increments To load and use the 4-way tool post Compound SlideTool Posts To set the compound slide angleConfiguring the V-Belts and Back Gear Spindle SpeedCalculating the Correct Spindle RPM To disengage the back gears To engage the back gearsPower Feed Setting Feed Rate Recommended Feed RatesTo set the feed rate Change Gears To re-configure the change gearsChange gear. G9249 12 x 37 Belt Drive Gap Bed Lathe Side Front ViewTo cut threads Threading OperationEdhidc H3022-Measurement Tool Set AccessoriesH2670-HSS Square Tool Bits Pc. Carbide Tipped Tool Bit SetsH5936-2 Pc. Knurling Tool Set H2996-Double Ended Boring BarG1070-MT3 Live Center Set H6879-Lathe Operation & Maintenance BookMaintenance Cleaning ProtectingSchedule To add oil to the spindle bearing reservoirs LubricationSpindle Bearing Oil Lubricant Frequency QtyHeadstock Spindle Pulley Shaft Headstock Change GearsHeadstock Idler Pulley Shaft Headstock GearsFeed Rate Gears Apron GearboxTo lubricate the feed rate gears Back Gear Shaft Ball OilersReplacing Motor V-Belt Adjusting Motor V-BeltTo adjust the motor V-belt tension Tensioning Replacing V-BeltsSpindle V-Belt Power Twist V-Belt G9249 12 x 37 Belt Drive Gap Bed LatheService TroubleshootingMotor & Electrical Faceplate Operations Adjusting Gibs To adjust the saddle gibTo adjust the cross slide and compound slide gibs Cross Slide Backlash To adjust the tailstock lockTo adjust the cross slide backlash Tailstock LockSpindle Bearing Preload Gap RemovalDisconnect Lathe from Power To confirm that the bearings are correctly pre- loaded Type of Finger Tip Part Number To remove/install the rest fingersTo remove/install the brass tips Rest Finger TipsTo adjust the half-nut guide bar Adjusting Half-NutElectrical Safety Instructions WiringMotor Wiring OverviewDiagram on Control PanelElectrical Cabinet Wiring Diagram Box Control Panel & Motor Wiring DiagramsBed PartsHeadstock Figured Flat NUT M8-1.25 Headstock Parts ListBushing Feed Rate Gearbox Feed Rate Gearbox Parts List Apron Apron Parts List + + Carriage Parts List #* #+ Spindle Lever Change Gear Cover Complete Steady Rest Complete Follow Rest Electrical Cabinet Electrical Cabinet Parts List Cabinet Stand Accessories Label Placement 22!.49 #!2$ 99.$5342!, .# 0//88 %,,.!- 7!  Warranty and Returns #ALL 4ODAYD&ORO! &2%%