Quadra-Fire CB1200-B owner manual CB 1200 Pellet Stove Clearances to Combustibles UL and ULC

Page 8

CB 1200 Pellet Stove

R

B. Clearances to Combustibles (UL and ULC)

Alcove Installation

Inches

Millimeters

Minimum Alcove Height

44

1117

A

B

C

C

Minimum Alcove Width

40-1/2

1029

Maximum Alcove Depth

36

915

Minimum Alcove Side Wall

6

152

Top of Unit to Combustibles

12-1/2

318

WARNING

Straight Back Against

Inches

Millimeters

Wall

 

 

 

A

 

Back Wall to Appliance

2

51

B

 

Side Wall to Appliance

6

152

 

 

 

Corner Installation

Inches

Millimeters

C

 

Walls to Appliance

2

51

Installations with:

3 to 3 inch Top Vent Adapter and

3 to 6 inch Offset Adapter Kit

Fire Risk.

Comply with all minimum clearances to combustibles as specified.

Failure to comply may cause house fire.

NOTE:

Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY.

Illustrations/diagrams are not drawn to scale.

Actual installation may vary due to individual design preference.

D

F

 

 

E

G

G

Vertical Installation

Inches

Millimeters

D

Back Wall to Flue Pipe

3

76

E

Side Wall to Top

6

152

F

Back Wall to Appliance

7.5

191

 

 

 

Corner Installation

Inches

Millimeters

G

Walls to Appliance

2

51

Page

7014-082D

September 1, 2008

Image 8
Contents Classic BAY 1200 Pellet Stove Hot glass will cause burnsTesting Lab & Report Number CB 1200 Pellet StoveBehind left side curtain on outside of hopper wall Serial Number ModelTable of Contents Listing and Code Approvals Design, Installation & Location Considerations Fire SafetyGetting Started Appliance LocationCB 1200 Pellet Stove Tools And Supplies Needed Inspect Appliance & Components and Pre-Use Check ListDimensions and Clearances Appliance DimensionsCB 1200 Pellet Stove Clearances to Combustibles UL and ULC Hearth Pad Requirements Exception for Horizontal InstallationsCB 1200 Pellet Stove Hearth Pad Requirements UL and ULC Vent Information Example of 3 Elbow-Rear Vent Termination Calculaton Pipe Selection ChartCB 1200 Pellet Stove Equivalent Feet of Pipe 5Venting Systems AlcoveCB 1200 Pellet Stove Through The Wall Straight OutDegree CB 1200 Pellet Stove Vertical Through The Wall & VerticalMasonry Alternate MasonryMobile Home Outside Air Kit Instructions Rear Installation Floor InstallationAppliance Set-Up CB 1200 Pellet Stove Top Vent Adapter Installation Rear Vent and Rear Vent to Top Vent Adapter InstallationInstalling the Top Vent Adapter See FigureCB 1200 Pellet Stove Optional Brick Set Installation Brick Clip InstallationInstalling Logo Nickel Only Charred Areas in the BackTop Log, Left RightDoor Installation CB 1200 Pellet Stove Thermostat InstallationTo install door To adjust latchesOperating Instructions Fuel Size And Material General Operating InformationFeed Rate Adjustment Instructions Starting Your First FireFrequently Asked Questions CB 1200 Pellet Stove Ignition CyclesPossible Cause Corrective Action TroubleshootingSymptom Page Page Quick Reference Maintenance Chart 10Maintaining & Servicing Your ApplianceFrequency Daily Weekly Monthly Yearly Types of FuelCleaning Firepot with Cleaning Rod & Firepot Scraper Cleaning Ash PanCleaning Heat Exchanger Chambers & Drop Tube Ash Removal from FireboxCleaning Beneath Heat Exchanger Cleaning Exhaust PathCleaning the Glass Cleaning the HopperCleaning the Top Vent Adapter Preparing Firebox for Non-Burn Season Frequency YearlyCB 1200 Pellet Stove High Ash Fuel Content Maintenance Convection Blower ReplacementRe-install blower to blower housing Exhaust Blower Replacement Remove existing blowerInstall new blower Glass Replacement Replacing Side GlassReference Materials Component Function & LocationVacuum Switch Wiring Harness See .1 belowSnap Disc #1 Convection Blower 145F Snap Disc #2 Thermostat Override 200FCleaning Rods Heat Exchanger Tubes CB 1200 Pellet Stove Component LocationsGlass Size Sides 8 wide x 11 high CB 1200 Pellet Stove Exploded ViewsGlass Size Center 13-7/8 wide x 11 high Nbr Description CB 1200 Pellet Stove CB 1200 Pellet Stove Service Parts and Accessories Item # Parts Alphabetical OrderItem # Service Parts Alphabetical Order Accessories ApplianceCB 1200 Pellet Stove Service And Maintenance Log Date of Service Performed By Description of ServiceCB 1200 Pellet Stove Homeowner’s Notes CB 1200 Pellet Stove Warranty Policy CONDITIONS, Exclusions & Limitation of LiabilityHearth & Home Technologies Limited Warranty Cont’d Contact Information