Quadra-Fire 21M-ACC Millennium Wood Stove ACC Firebrick Replacement, To your authorized dealer

Page 30

2100 Millennium Wood Stove (ACC)

 

 

 

 

 

R

 

 

 

 

 

 

D. Firebrick Replacement

 

 

 

 

 

 

Replace the firebrick if they become crumbly and/or if

 

3

 

 

3

 

there is a 1/4 inch (6.35mm) gap between the bricks.

 

 

 

 

 

 

 

 

 

 

Inspect the firebrick after each ash removal.

1

 

 

 

 

1

The firebox is lined with high quality firebrick, which has

 

 

 

 

 

 

 

 

 

 

exceptional insulating properties. There is no need to

 

 

 

 

 

1

use a grate; simply build a fire on the firebox floor. Do

1

1

1

 

1

not operate appliance without firebrick.

 

 

 

 

 

 

1. After the coals have completely cooled, remove all

1

 

 

 

 

1

old brick and ash from unit and vacuum firebox.

 

2

 

 

 

 

2. Remove new brick set from box and lay out to

5

2

2

 

4

diagram shown.

 

 

 

 

 

 

3. Lay bottom bricks in unit.

 

 

 

 

 

 

4. Install rear bricks on the top of the bottom bricks.

 

 

 

 

 

 

Slide top of bricks under clip on back of firebox wall

 

 

 

 

 

 

and push bottom of brick back.

 

8-1/2 inches (216mm)

 

 

 

5. Install side bricks. Slide top of brick under clips

 

 

 

 

 

 

on side of firebox and push the bottom of the brick

 

 

 

 

 

1-3/8 in.

until it is flush with the side of the unit.

 

 

 

 

 

(35mm)

 

 

4

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

1-3/4 in.

Use Part 832-0550 when ordering individual brick. Provide brick

 

 

 

 

 

(44mm)

 

 

 

 

 

 

dimension or copy this page, mark the desired brick and take it

 

 

6-1/4 inches

 

 

 

to your authorized dealer.

 

 

(159mm)

 

 

 

 

 

 

 

 

 

 

 

7 inches (178mm)

 

 

 

 

5

 

 

3 inches

 

 

 

 

 

(76mm)

 

 

 

 

 

 

 

 

8-1/2 inches (216mm)

 

 

 

Figure 30.1

 

 

 

 

 

No.

Brick Size

Qty

1

9 x 4-1/2 x 1-1/4

9

2

6 x 4-1/2

3

3

8 x 4-1/2 x 1-1/4

2

4

Brick with angle (see drawing)

1

5

Brick with angle (see drawing)

1

Page 30

7039-131H

May 5, 2011

Page 29 Page 31
Image 30
Page 29 Page 31
Contents Hot glass will cause burns 7039-131H May 5Millennium Wood Stove ACC Serial No Model Name Test Lab & Report NoMfg. Date 7039-131H May 5 Table of Contents Listing and Code Approvals Appliance Certification BTU & Efficiency SpecificationsGlass Specifications Mobile Home ApprovedFire Safety Getting StartedAppliance needs to draft properly for safety Millennium Wood Stove ACC Negative PressureTools And Supplies Needed Millennium Wood Stove ACC Flue Draft ConsiderationsVenting Systems Inspect Appliance & Components Pre-Burn Check ListMillennium Wood Stove ACC Typical Stove Systems Masonry ChimneyDimensions and Clearances Appliance DimensionsBackwall / Sidewall Corner Installation See Figure InstallationRHearth Protection Requirements USA required Canada recommendedMillennium Wood Stove ACC Outside Air Kit Installation Items Needed for Installation not suppliedFloor Installation Alternative In some instances you Blower Optional 13-15/16 in mmVenting Components Chimney Systems Chimney ConnectorChimney Requirements ThimbleInstructions ComponentsAir Clearances Solid Pack Chimney with Metal Supports as a ThimbleSolid Pack Chimney with Metal Supports as a Thimble Cont’d Installing Chimney ComponentsSingle wall connector or stove pipe Chimney Height / Rise and RunPitched Roof Millennium Wood Stove ACC Chimney Termination RequirementsRule Flat RoofMobile Home Installation Door Handle Assembly Adjusting The Blower Speed Control Appliance Set-UpBurning Process Operating InstructionsOver-Firing Your Appliance Wood Selection & Storage Cont’d Wood Selection & StorageAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efficiency Millennium Wood Stove ACC Building a Fire Incorrect Positions Opacity Smoke Initial cold start-up and all Burn SettingsMillennium Wood Stove ACC Blower Operating Instructions Snap Disc LocationMillennium Wood Stove ACC Frequently Asked Questions Odor from applianceAppliance Quick Reference Maintenance Guide Maintaining & Servicing Your ApplianceGlass Cleaning Frequency As desired Millennium Wood Stove ACC General MaintenanceCreosote Chimney Cleaning Disposal of AshesGlass Replacement When cleaning glassMillennium Wood Stove ACC Firebrick Replacement To your authorized dealerCorrect Blanket & Baffle Position on BaffleMillennium Wood Stove ACC Tube Channel Assembly Replacement Removing Tube Channel AssemblyReplacing Tube Channel Assembly Troubleshooting Start Fire Problems Possible Cause Solution21M-ACC Millennium Wood Stove21M-ACC Stocked 21M-ACC Millennium Wood Stove ACC Service And Maintenance Log Date of Service Performed By Description of ServiceMillennium Wood Stove ACC Service And Maintenance Log Cont’d Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Warranty Policy Millennium Wood Stove ACC Contact Information
Top Page Image Contents