Quadra-Fire 21M-ACC Listing and Code Approvals, Mobile Home Approved, Glass Specifications

Page 4

2100 Millennium Wood Stove (ACC)

R

 

 

 

 

 

 

 

 

 

 

 

1 Listing and Code Approvals

 

 

 

 

 

 

A. Appliance Certification

D. BTU & Efficiency Specifications

Model:

2100 Millennium (ACC)

Laboratory:

OMNI Test Laboratories, Inc.

Report No & Date:

061-S-70-6

Type:

Listed Room Heater, Solid Fuel Type

Standard:

UL1482 and ULC S627-00 and

 

(UM) 84-HUD, Mobile Home

 

Approved.

NOTE: This installation must conform with local codes. In the absence of local codes you must comply with the UL1482, (UM) 84-HUD and NPFA211 in the U.S.A. and the ULC S627-00 and CAN/CSA-B365 Installation Codes in Canada.

EPA Certified:

2.1 grams per hour

EPA Certificate Number

Number: 664

and Date:

Issued: 07-20-2007

Efficiency:

78.5%

BTU Output:

12,000 to 28,800

Heating Capacity:

800 to 1,500 sq ft

 

depending on climate zone

Vent Size:

6 inches

Firebox Size:

1.46 cubic feet

Max Wood Length:

16 inches

Fuel:

Cord Wood

Shipping Weight:

300 lbs

The Quadra-Fire 2100 Millennium Wood Stove (ACC) meets the U.S. Environmental Protection Agency’s 1990 particulate emission standards.

B. Mobile Home Approved

•This appliance is approved for mobile home installations when not installed in a sleeping room and when an out- side combustion air inlet is provided.

•The structural integrity of the mobile home floor, ceiling, and walls must be maintained.

•The appliance must be properly grounded to the frame of the mobile home with #8 copper ground wire, and use only listed double-wall connector pipe.

•Outside Air Kit, part OAK-ACC must be installed in a mo- bile home installation.

C. Glass Specifications

This stove is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contact your dealer for replacement glass.

Quadra-Fire is a registered trademark of Hearth & Home Technologies.

WARNING

Fire Risk.

Hearth & Home Technologies disclaims any responsibility for, and the warranty will be voided by, the following actions:

•Installation and use of any damaged appliance.

•Modification of the appliance.

•Installation other than as instructed by Hearth & Home Technologies.

•Installation and/or use of any component part not approved by Hearth & Home Technologies.

•Operating appliance without fully assembling all components.

•Operating appliance without legs attached (if supplied with unit).

•Do NOT Overfire - If appliance or chimney connector glows, you are overfiring.

Any such action that may cause a fire hazard.

Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

For assistance or additional information, consult a qualified installer, service agency or your dealer.

NOTE: Hearth & Home Technologies, manufacturer of this appliance, reserves the right to alter its products, their specifications and/or price without notice.

Page 4

7039-131H

May 5, 2011

Page 3 Page 5
Image 4
Page 3 Page 5
Contents Hot glass will cause burns 7039-131H May 5Serial No Model Name Test Lab & Report No Millennium Wood Stove ACCMfg. Date 7039-131H May 5 Table of Contents Appliance Certification BTU & Efficiency Specifications Glass SpecificationsListing and Code Approvals Mobile Home ApprovedFire Safety Getting StartedAppliance needs to draft properly for safety Millennium Wood Stove ACC Negative PressureMillennium Wood Stove ACC Flue Draft Considerations Venting SystemsTools And Supplies Needed Inspect Appliance & Components Pre-Burn Check ListMillennium Wood Stove ACC Typical Stove Systems Masonry ChimneyDimensions and Clearances Appliance DimensionsBackwall / Sidewall Corner Installation InstallationR Hearth Protection RequirementsSee Figure USA required Canada recommendedItems Needed for Installation not supplied Millennium Wood Stove ACC Outside Air Kit InstallationFloor Installation Alternative In some instances you Blower Optional 13-15/16 in mmChimney Connector Chimney RequirementsVenting Components Chimney Systems ThimbleComponents Air ClearancesInstructions Solid Pack Chimney with Metal Supports as a ThimbleInstalling Chimney Components Single wall connector or stove pipeSolid Pack Chimney with Metal Supports as a Thimble Cont’d Chimney Height / Rise and RunMillennium Wood Stove ACC Chimney Termination Requirements RulePitched Roof Flat RoofMobile Home Installation Door Handle Assembly Adjusting The Blower Speed Control Appliance Set-UpOperating Instructions Over-Firing Your Appliance Wood Selection & Storage Cont’dBurning Process Wood Selection & StorageAutomatic Combustion Control ACC Air ControlsBurn Rates and Operating Efficiency Millennium Wood Stove ACC Building a Fire Incorrect Positions Initial cold start-up and all Burn Settings Millennium Wood Stove ACC Blower Operating InstructionsOpacity Smoke Snap Disc LocationOdor from appliance Millennium Wood Stove ACC Frequently Asked QuestionsAppliance Quick Reference Maintenance Guide Maintaining & Servicing Your ApplianceMillennium Wood Stove ACC General Maintenance Creosote Chimney CleaningGlass Cleaning Frequency As desired Disposal of AshesGlass Replacement When cleaning glassMillennium Wood Stove ACC Firebrick Replacement To your authorized dealerCorrect Blanket & Baffle Position on BaffleRemoving Tube Channel Assembly Millennium Wood Stove ACC Tube Channel Assembly ReplacementReplacing Tube Channel Assembly Troubleshooting Start Fire Problems Possible Cause Solution21M-ACC Millennium Wood Stove21M-ACC Stocked 21M-ACC Millennium Wood Stove ACC Service And Maintenance Log Date of Service Performed By Description of ServiceMillennium Wood Stove ACC Service And Maintenance Log Cont’d Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Warranty Policy Millennium Wood Stove ACC Contact Information
Top Page Image Contents