Quadra-Fire 21M-ACC owner manual Getting Started, Fire Safety

Page 5

 

R

2100 Millennium Wood Stove (ACC)

 

 

 

 

 

 

2

Getting Started

 

 

 

A. Design, Installation & Location Considerations

Consideration must be given to:

•Safety

•Convenience

•Traffic flow

•Chimney and chimney connector required

It is a good idea to plan your installation on paper, using exact measurements for clearances and floor protection, before actually beginning the installation. If you are not using an existing chimney, place the appliance where there will be a clear passage for a factory-built listed chimney through the ceiling and roof.

We recommend that a qualified building inspector and your insurance company representative review your plans before and after installation

If this appliance is in an area where children may be near it is recommended that you purchase a decorative barrier to go in front of the appliance. Remember to always keep children away while it is operating and do not let anyone operate this appliance unless they are familiar with these operating instructions.

NOTE: Service Space

In order to replace the tube channel a clearance of 17 inches (432mm) is required on the right side of stove in order to remove the tubes with the stove in place.

If space is not available, the stove will have to be discon- nected from the chimney to proceed with the tube replace- ment. See page 32.

CAUTION

Check building codes prior to installation.

•Installation MUST comply with local, regional, state and national codes and regulations.

•Consult insurance carrier, local building, fire officials or authorities having jurisdiction about restrictions, installation inspection, and permits.

B. Fire Safety

To provide reasonable fire safety, the following should be given serious consideration:

1.Install at least one smoke detector on each floor of your home to ensure your safety. They should be located away from the heating appliance and close to the sleeping areas. Follow the smoke detector manufacturer’s placement and installation instructions, and be sure to maintain regularly.

2.A conveniently located Class A fire extinguisher to contend with small fires resulting from burning embers.

3.A practiced evacuation plan, consisting of at least two escape routes.

4.A plan to deal with a chimney fire as follows: In the event of a chimney fire:

a Evacuate the house immediately b. Notify fire department

WARNING

Fire Risk.

Hearth & Home Technologies disclaims any responsibility for, and the warranty will be voided by, the following actions:

•Installation and use of any damaged appliance.

•Modification of the appliance.

•Installation other than as instructed by Hearth & Home Technologies.

•Installation and/or use of any component part not approved by Hearth & Home Technologies.

•Operating appliance without fully assembling all components.

•Operating appliance without legs attached (if supplied with unit).

•Do NOT Overfire - If appliance or chimney connector glows, you are overfiring.

Any such action that may cause a fire hazard.

WARNING

Asphyxiation Risk.

•DO NOT CONNECT THIS UNIT TO A CHIM- NEY FLUE SERVICING ANOTHER APPLI- ANCE.

•DO NOT CONNECT TO ANY AIR DISTRIBU- TION DUCT OR SYSTEM.

May allow flue gases to enter the house.

WARNING

Fire Risk.

•Do not operate appliance before reading and understanding operating instructions.

•Failure to operate appliance properly may cause a house fire.

May 5, 2011

7039-131H

Page 5

Page 4 Page 6
Image 5
Page 4 Page 6
Contents 7039-131H May 5 Hot glass will cause burnsMfg. Date 7039-131H May 5 Millennium Wood Stove ACCSerial No Model Name Test Lab & Report No Table of Contents Glass Specifications Appliance Certification BTU & Efficiency SpecificationsListing and Code Approvals Mobile Home ApprovedGetting Started Fire SafetyMillennium Wood Stove ACC Negative Pressure Appliance needs to draft properly for safetyVenting Systems Millennium Wood Stove ACC Flue Draft ConsiderationsTools And Supplies Needed Inspect Appliance & Components Pre-Burn Check ListMasonry Chimney Millennium Wood Stove ACC Typical Stove SystemsAppliance Dimensions Dimensions and ClearancesBackwall / Sidewall Corner Installation Hearth Protection Requirements InstallationRSee Figure USA required Canada recommendedFloor Installation Alternative In some instances you Millennium Wood Stove ACC Outside Air Kit InstallationItems Needed for Installation not supplied 13-15/16 in mm Blower OptionalChimney Requirements Chimney ConnectorVenting Components Chimney Systems ThimbleAir Clearances ComponentsInstructions Solid Pack Chimney with Metal Supports as a ThimbleSingle wall connector or stove pipe Installing Chimney ComponentsSolid Pack Chimney with Metal Supports as a Thimble Cont’d Chimney Height / Rise and RunRule Millennium Wood Stove ACC Chimney Termination RequirementsPitched Roof Flat RoofMobile Home Installation Appliance Set-Up Door Handle Assembly Adjusting The Blower Speed ControlOver-Firing Your Appliance Wood Selection & Storage Cont’d Operating InstructionsBurning Process Wood Selection & StorageAir Controls Automatic Combustion Control ACCBurn Rates and Operating Efficiency Millennium Wood Stove ACC Building a Fire Incorrect Positions Millennium Wood Stove ACC Blower Operating Instructions Initial cold start-up and all Burn SettingsOpacity Smoke Snap Disc LocationAppliance Millennium Wood Stove ACC Frequently Asked QuestionsOdor from appliance Maintaining & Servicing Your Appliance Quick Reference Maintenance GuideCreosote Chimney Cleaning Millennium Wood Stove ACC General MaintenanceGlass Cleaning Frequency As desired Disposal of AshesWhen cleaning glass Glass ReplacementTo your authorized dealer Millennium Wood Stove ACC Firebrick ReplacementBaffle Correct Blanket & Baffle Position onReplacing Tube Channel Assembly Millennium Wood Stove ACC Tube Channel Assembly ReplacementRemoving Tube Channel Assembly Start Fire Problems Possible Cause Solution TroubleshootingMillennium Wood Stove 21M-ACC21M-ACC Stocked 21M-ACC Date of Service Performed By Description of Service Millennium Wood Stove ACC Service And Maintenance LogMillennium Wood Stove ACC Service And Maintenance Log Cont’d Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Warranty Policy Millennium Wood Stove ACC Contact Information
Top Page Image Contents