Quadra-Fire 21M-ACC owner manual Correct Blanket & Baffle Position on

Page 31

R

2100 Millennium Wood Stove (ACC)

E. Baffle Removal

F. Snap Disc Replacement

1.Remove all ash from the firebox, and extinguish all hot embers before disposal into a metal container.

2.The baffle board has 2 pieces. With the ceramic blanket still in place, slide one baffle piece over the top of other one and pull out top piece through the door opening and then remove bottom baffle piece. Figure 31.1.

3.Remove the ceramic blanket.

4.Re-install the baffle pieces one piece at a time. Be sure the baffle boards are even with the front manifold tube and is resting on all tubes. Figure 23.1 on page 23. See Also

Correct Blanket & Baffle Position on page 24.

5.To re-install the ceramic blanket, it is easier to fold it in half first. Figure 31.2. Place on top of baffle board, open up and flatten and smooth out the blanket. Re-check the baffle board for correct positioning. Figure 23.1 on page 23 and page 24.

Figure 31.1 - Baffle

1.Locate the snap disc bracket assembly at the bottom left rear corner of the stove. Figure 31. 3.

2.A magnet holds the bracket to the stove. Pull the bracket down away from the stove to expose the snap disc.

3.Pull the snap disc and spade connectors up and out of bracket as shown in Figure 31.4.

4.Using a Phillips head screw driver, remove the 2 screws from the snap disc and then remove the snap disc from the spade connectors. Replace with new snap disc and re-connect to spade connectors.

5.Push the snap disc and spade connectors back inside bracket and re-attach the bracket to the stove.

Snap Disc Location

Figure 31.3

Figure 31.2 - Ceramic Blanket

Snap Disc

Magnet

Spade

Connectors

Figure 31.4

May 5, 2011

7039-131H

Page 31

Image 31

Contents 7039-131H May 5 Hot glass will cause burnsSerial No Model Name Test Lab & Report No Millennium Wood Stove ACCMfg. Date 7039-131H May 5 Table of Contents Mobile Home Approved Appliance Certification BTU & Efficiency SpecificationsGlass Specifications Listing and Code ApprovalsGetting Started Fire SafetyMillennium Wood Stove ACC Negative Pressure Appliance needs to draft properly for safetyInspect Appliance & Components Pre-Burn Check List Millennium Wood Stove ACC Flue Draft ConsiderationsVenting Systems Tools And Supplies NeededMasonry Chimney Millennium Wood Stove ACC Typical Stove SystemsAppliance Dimensions Dimensions and ClearancesBackwall / Sidewall Corner Installation USA required Canada recommended InstallationRHearth Protection Requirements See FigureItems Needed for Installation not supplied Millennium Wood Stove ACC Outside Air Kit InstallationFloor Installation Alternative In some instances you 13-15/16 in mm Blower OptionalThimble Chimney ConnectorChimney Requirements Venting Components Chimney SystemsSolid Pack Chimney with Metal Supports as a Thimble ComponentsAir Clearances InstructionsChimney Height / Rise and Run Installing Chimney ComponentsSingle wall connector or stove pipe Solid Pack Chimney with Metal Supports as a Thimble Cont’dFlat Roof Millennium Wood Stove ACC Chimney Termination RequirementsRule Pitched RoofMobile Home Installation Appliance Set-Up Door Handle Assembly Adjusting The Blower Speed ControlWood Selection & Storage Operating InstructionsOver-Firing Your Appliance Wood Selection & Storage Cont’d Burning ProcessAir Controls Automatic Combustion Control ACCBurn Rates and Operating Efficiency Millennium Wood Stove ACC Building a Fire Incorrect Positions Snap Disc Location Initial cold start-up and all Burn SettingsMillennium Wood Stove ACC Blower Operating Instructions Opacity SmokeOdor from appliance Millennium Wood Stove ACC Frequently Asked QuestionsAppliance Maintaining & Servicing Your Appliance Quick Reference Maintenance GuideDisposal of Ashes Millennium Wood Stove ACC General MaintenanceCreosote Chimney Cleaning Glass Cleaning Frequency As desiredWhen cleaning glass Glass ReplacementTo your authorized dealer Millennium Wood Stove ACC Firebrick ReplacementBaffle Correct Blanket & Baffle Position onRemoving Tube Channel Assembly Millennium Wood Stove ACC Tube Channel Assembly ReplacementReplacing Tube Channel Assembly Start Fire Problems Possible Cause Solution TroubleshootingMillennium Wood Stove 21M-ACC21M-ACC Stocked 21M-ACC Date of Service Performed By Description of Service Millennium Wood Stove ACC Service And Maintenance LogMillennium Wood Stove ACC Service And Maintenance Log Cont’d Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Homeowner’s Notes Millennium Wood Stove ACC Warranty Policy Millennium Wood Stove ACC Contact Information