Kenmore
153.33114, 153.33115
manual
Install
Expansion Tank Sizing Chart
Problem
Vent Connectors
Control/Temperature Knob
Weight
Gas Pressure Testing
Replacement Parts
Service
Page 43
43
Page 42
Page 44
Image 43
Page 42
Page 44
Contents
320391-000
Sears Brands Management Corporation
Model No
153.331140 40 Gallon 153.331150 50 Gallon
Important Definitions
Read and follow water heater warnings and instructions
Explosion Hazard
Improper installation and use may result in property damage
Fire or Explosion Hazard
Fire Hazard
12-15
Installation
Vent Pipe System Draft Hood Installation
Vent Connectors 19-20
StartUpConditions
OperatingtheTemperatureControlSystem
Service
LightingInstructions
Year Limited Warranty on Water Heater
Important Information About This Water Heater
Excessive Weight Hazard
Model
Materials Needed
Status Mark Light
Control/Temperature Knob
Temperatures shown are approximates and may vary
Vent Pipe Inner Door
Installation Checklist
Manual GAS
Removing the Old Water Heater
Fire or Explosion Hazard
Location Requirements
Site Location
Carbon Monoxide Poisoning Hazard
All water heaters eventually leak
Insulation Blankets
Property Damage Hazard
Breathing Hazard Carbon Monoxide Gas
Property Damage Hazard
Filling the Water Heater
Gas Requirements
Gas Piping
Explosion Hazard
Gas Pressure Testing
Gas Pressure
LP Gas Only
Confined Space
Carbon Monoxide Warning
Unconfined Space
All Air from Inside the Building
Louvers and Grilles
All Air from Outdoors
Vent Pipe System
Draft Hood Installation
Vent Connectors
Vent Pipe Size
Opposite wall of the chimney Figure
Chimney Connection
Vertical Exhaust Gas Vent
Chimney as it may restrict the space between it
Isectn 19 MGL
Piping Installation
Lminimum
Closed System/Thermal Expansion
Temperature and Pressure Relief Valve
If the Pilot Does Not Light
Lighting Instructions
Lighting the Pilot
If the Status Light Does Not Blink
IgniterGASCONTROL
STOP!It is imyou readall safety lightingthe pilot
Refertothe UghtingInstructionsinthe Installation
Phone. Follow the gas supptiersinstructions
Emergency Shut Down
Water Temperature Regulation
Checking the Draft
Burner Flames
Status Light Code Normal Flashes
Operating the Temperature Control System
Fiue gases may escape if ,vent pipe is not connected
Vent System Inspection
Burner Inspection
Carbon Monoxide and Fire Hazard
Fire and Explosion Hazard
Housekeeping
Anode Rod Inspection
Draining and Flushing
Service
Removing the Burner from the Manifold Burner Assembly
Replacement Parts
External Inspection & Cleaning Base-Ring Filter
Removing the Manifold/Burner Assembly
Burneran other
Cleaning the Combustion Chamber and Flame-arrestor
Explosion Hazard
Replacing the Manifold/Burner Assembly
Piezoelectric Igniter System
Removing the Gas Control Valve/Thermostat
Removing and Replacing the Gas Control Valve/Thermostat
Strange Sounds
Thermal Ex ansion Tank Specifications
Expansion Tank Sizing Chart
Start Up Conditions
AIR In Hot Water Faucets
Safety Shut-off and Thermal Switch
Operational Conditions
Condensation
Before installing, operating or servicing this water heater
Problem
Thermostat Not functioning properly Replace
Water heater flue or vent system
Blocked
Excessive Waterpressure Use Pressure Reducing Valve
Normal Operation
Pilot light was recently extinguished
Thermopile is cooling
Down
Gas Control Valve failure
Temperature Sensor Thermistor Is defective
800-4694663
=N01
Section Pilot light Repeatedly Goes out
153.331150 Gallon
153.331140 Gallon
Model
Page
MY-HOME
Top
Page
Image
Contents