New Buck Corporation Heater Model 80 Residential Freestanding Room Heater Installation, Section

Page 13

SECTION III

RESIDENTIAL FREESTANDING ROOM HEATER

INSTALLATION

INSTALLATION PRECAUTION

Extensive field and laboratory testing has shown that catalytic stoves perform best as freestanding stoves when vented into a masonry chimney that include the following:

1.A rain cap is installed on the chimney.

2.Height of chimney is at least 15 feet high.

3.Location of chimney is interior (not on an outside wall).

Satisfactory results have been reported with installations other than listed above. However, draft problems are possible if a hot chimney is not maintained.

Use pedestal kit as follows:

Model 80 #4171B

CAUTION: Do not connect this unit to a chimney flue serving another appliance.

Image 13

Contents OPERATION MAINTENANCE SAFETY FEATURES PREPARATION INSTALLATIONSAFETY NOTICE “MEETS PHASE II EPA STANDARDS”Page SECTION TABLE OF CONTENTSSECTION SECTIONPage SECTION ROOM HEATER FEATURESModel 80 Wood Stove EPA COMPLIANCE STATUS CATALYST WARRANTYCATALYST EQUIPPED PROPER FUEL SELECTIONCATALYST MONITORING ACHIEVING CATALYTIC LIGHT-OFFWHEN REFUELINGCAUTION AGAINST OVER-FIRING ASH REMOVALINSTALLATIONS Fireplace Insert MASONRY INSERT INSTALLATIONREQUIRED FIREPLACE DIMENSIONS INSTALLATION PRECAUTIONSINSTALLATION PREPARATION POSSIBLE TOOLS NEEDED FOR INSTALLATIONPOSITIONING THE HEATER FireplaceMOUNTING THE TRIM PANELS FINAL CHECK INSTALLATION PRECAUTION RESIDENTIAL FREESTANDING ROOM HEATER INSTALLATIONSECTION FLOOR PROTECTION TOOLS FOR INSTALLATIONMODEL Minimum Clearances CHIMNEY Preparing The Stove for InstallationDETERMINING THE CHIMNEY LOCATION Wall Exit Into Metal Tee-Box Wall Exit Into Masonry using single wall pipeCeiling Exit-CloseClearance FINAL CHECK ALTERNATIVES FOR WALL PROTECTIONTested and Listed Wall Protector Unlisted and Untested Wall Protector3.Open the primary air drafts and damper bypass SECTION WOOD HEATER SAFETYOPERATION GUIDE TO THE DIFFERENT BURNING QUALITIES OF WOODSECTION Building a Fire GASKET REPLACEMENT Cold Heater Disassembly Inspection and Catalytic ReplacementPREVENTIVE MAINTENANCE / PARTS REPLACEMENT SECTIONPage Problem TROUBLESHOOTINGSolution SECTIONSolution ProblemCOMBUSTOR-RELATEDPROBLEMS Possible CauseNEW BUCK CORPORATION NBC