New Buck Corporation Heater Model 80 manual Model 80 Wood Stove

Page 6

Model 80 Wood Stove

Model 80 Wood Stove

14

10

39

13

	40
5	11		4	20
	1	21		20
		21		32
				32
				7
				37

15

&	38

33 18

15 8

19

3A

35

		Buck	17	23	31
		Stove		23	31
					27
		28				2
		28
		6		16		9
	36	34		16	30	9
		34			30
		29			26
		29	25		26
			25		22
				24

3

12

1.	By Pass Damper & Brass Spring Handle	21.	Lower Heat Shield
2.	Blower Control (Rheostat)	22.	Leveling Screws
3.	Primary Air Control (Right Side)	23.	Bottom Firebrick
3a.	Primary Air Control (Left Side)	24.	Motor
4.	Warm Air Outlets	25.	Motor Mount Bracket
5.	Baffles (Interior of Stove)	26.	Cover Door
6.	Air Inlet	27.	Cover Door Screws
7.	Door	28.	Shot Gun Air Box
8.	Hearth Extension	29.	Ash Pan
9.	Power Cord	30.	Disc Thermostat
10.	Catalyst (interior firebox)	31.	Door Handle & Brass Spring Handle
11.	Catalyst Probe	32.	Air Wash Screen
12.	Automatic / Off / Man. Switch	33.	Glass Gasket
13.	Brass Cap	34.	Cover Door Hinge
14.	Hinge Block	35.	Magnet Holder
15.	Air Control Brass Knobs	36.	Cover Door Magnet
16.	Shot Gun Air Control	37.	Door Latch
17.	Door Glass	38.	Door Latch Screw
18.	Glass Clips	39.	Hinge Pins
19.	Hearth Brass	40.	8" Flue Exit
20.	Door Gasket

4

Image 6

Contents SAFETY NOTICE FEATURES PREPARATION INSTALLATIONOPERATION MAINTENANCE SAFETY “MEETS PHASE II EPA STANDARDS”Page SECTION TABLE OF CONTENTSSECTION SECTIONPage ROOM HEATER FEATURES SECTIONModel 80 Wood Stove CATALYST EQUIPPED CATALYST WARRANTYEPA COMPLIANCE STATUS PROPER FUEL SELECTIONCAUTION AGAINST OVER-FIRING ACHIEVING CATALYTIC LIGHT-OFFWHEN REFUELINGCATALYST MONITORING ASH REMOVALREQUIRED FIREPLACE DIMENSIONS MASONRY INSERT INSTALLATIONINSTALLATIONS Fireplace Insert INSTALLATION PRECAUTIONSPOSITIONING THE HEATER POSSIBLE TOOLS NEEDED FOR INSTALLATIONINSTALLATION PREPARATION FireplaceMOUNTING THE TRIM PANELS FINAL CHECK RESIDENTIAL FREESTANDING ROOM HEATER INSTALLATION INSTALLATION PRECAUTIONSECTION TOOLS FOR INSTALLATION FLOOR PROTECTIONMODEL Minimum Clearances Preparing The Stove for Installation CHIMNEYDETERMINING THE CHIMNEY LOCATION Wall Exit Into Masonry using single wall pipe Wall Exit Into Metal Tee-BoxCeiling Exit-CloseClearance Tested and Listed Wall Protector ALTERNATIVES FOR WALL PROTECTIONFINAL CHECK Unlisted and Untested Wall Protector3.Open the primary air drafts and damper bypass WOOD HEATER SAFETY SECTIONGUIDE TO THE DIFFERENT BURNING QUALITIES OF WOOD OPERATIONSECTION Building a Fire PREVENTIVE MAINTENANCE / PARTS REPLACEMENT Disassembly Inspection and Catalytic ReplacementGASKET REPLACEMENT Cold Heater SECTIONPage Solution TROUBLESHOOTINGProblem SECTIONCOMBUSTOR-RELATEDPROBLEMS ProblemSolution Possible CauseNEW BUCK CORPORATION NBC