New Buck Corporation MODEL FP-327-ZC manual Flame Check, Natural Pilot, Burner, Propane Pilot

Page 31
FLAME CHECK

FLAME CHECK

A periodic check of the flames should be made. The pilot flame should always be present when the unit is in operation.

FLAME: Propane (LP) should produce a flame that is 3" to 4" above rear log. This flame should be yellow.

Natural gas should produce a flame that is 3" to 4" above rear log. This flame should be mostly blue except for the top 1/2" which should be yellow.

NATURAL PILOT

BURNER

PROPANE PILOT

 

Figure 14

Page 29

Page 30 Page 32
Image 31
Page 30 Page 32
Contents 8000 Highway 226 South Spruce Pine, NC MODEL FP-327-ZCNEW BUCK CORPORATION Manufacturer NEW BUCK CORPORATION P.O. BoxPage TABLE OF CONTENTS Page SECTION I SAFETY INFORMATION WARNINGS Page Page DRAFTS SECTION ZERO CLEARANCE INSTALLATIONCHOOSING THE LOCATION FOR YOUR FIREPLACE GAS LINEPage Fireplace and Framing Dimensions inches3 1/4 7 1/2Framing the Firebox INSTALLING THE FIREBOXFIREPLACE CLEARANCES Install the FireboxCLEARANCES FINISHING YOUR FIREPLACEMANTEL 3/4 FLAT SURFACE MANTEL PROFILES FOR ZERO CLEARANCE CABINETMUST BE FOLLOWED MANTEL 3/4 FLAT SURFACEWITH OPTIONAL WOODEN MANTEL INSTALLATION OF MODEL FP - 327- ZCMANTEL BASE 1/2 WOOD SCREWSTOP MANTEL REAR OF HEATERSECTION AFTER MARKET MOBILE HOME INSTALLATION DETERMINING FRESH-AIRFLOW FOR HEATER LOCATION PRODUCING ADEQUATE VENTILATIONVent-freeheater VENTILATION AIR FROM INSIDE BUILDING VENTILATION AIRVENTILATION AIR FROM OUTDOORS FLAME GAS CONNECTIONSEE DIAGRAM ON PAGE PLACEMENT OF LOGSGAS PRESSURE CHECK 3 1 2 Figure PLACEMENT OF LOGSPage LIGHTING INSTRUCTIONS MILLIVOLT VALVE ITT FOR YOUR SAFETY, READ BEFORE LIGHTINGWHAT TO DO IF YOU SMELL GAS Page ROCKER SWITCHBEFORE INSTALLING THERMOSTAT REMOVE METAL CONNECTORPage IGNITOR ELECTRODEPILOT BURNER THERMO--COUPLEPILETHERMOSTAT CONTROL OPERATION MANUAL LIGHTING PROCEDUREFOR YOUR SAFETY, READ BEFORE LIGHTING LIGHTING INSTRUCTIONS MODULATING VALVEMAXITROLfor “HIGH” LIGHTING INSTRUCTIONSto IGNITE and for “LOW”O.D.S PILOT BURNER IGNITER ELECTRODE THERMO-COUPLETO TURN OFF GAS TO APPLIANCE THERMOSTAT CONTROL OPERATION MANUAL LIGHTING PROCEDUREPROPANE PILOT FLAME CHECKNATURAL PILOT BURNERWIRING DIAGRAM Rating 120 volts/60HZ/0.54 Amps NOTE #PESBRO84 Blower Model FP-327-ZCPage CLEANING IMPORTANT SAFEGUARDSTROUBLE SHOOTING Air in gas lines when OBSERVED PROBLEM OBSERVED SERVICING REPAIR PARTSMaxitrol Valve PARTS LISTPage BLOWN UP VIEW OF BURNER ASSEMBLYPARTS LIST ITT ValvePage BLOWN UP VIEW OF BURNER ASSEMBLYPage Page
Top Page Image Contents