Desa VSGF36NTB, VSGF36PTB, VSGF36NRB Installing Firebox Using, Optional Accessory Mantels

Page 13

Installation

Continued

Installing Firebox USING

OPTIONAL ACCESSORY MANTELS

WARNING:Aqualifiedservice person must install firebox. Fol- low all local codes.

This firebox may be installed using the corner or cabinet mantel with hearth base accessories against a wall in your home. A trim kit is included with the mantel accessories (see Accessories, page 31).

1.Assemble cabinet mantel, hearth base, and trim accessories. Assembly instructions are included with each accessory.

2.Install gas piping to firebox location. See

Installing Gas Piping to Fireplace Location. You may have to cut a hole in the floor or wall to run gas line to firebox. Make sure to locate access hole so it is covered by mantel/base when installed.

3.Place hearth base against wall at installation location. Cut an access hole in hearth top to run flexible gas line to firebox (see Figure 11). Make sure to locate access hole so cabinet mantel will cover it when installed. Note: You can secure base to floor using wood screws. Countersink screw heads and putty over.

4.Route flexible gas line through access hole in hearth base.

5.Center cabinet mantel on hearth base (see Figure 12). Make sure mantel is flush against wall.

6.Install trim kit furnished with mantel. See instruction sheet included with mantel.

7.Carefully insert firebox into cabinet mantel. Be careful not to scratch firebox, mantel, base, etc. when installing (see Figure 13).

Hearth

Rigid Pipe and

Gas Line

Gas Shutoff

Access

Base

Valve

Hole

 

Figure 11 - Placing Hearth Base

Accessory Against Wall

Mantel

Hearth

Base

Figure 12 - Center Mantel on Hearth Base

Figure 13 - Inserting Firebox Into

Cabinet Mantel (Model May Vary From

Illustration)

Installing Gas Piping to Fireplace Location

WARNING: This appliance requires a 1/2" NPT (National Pipe Thread) inlet connection to the pressure regulator.

WARNING:Aqualifiedservice person must connect fireplace to gas supply. Follow all local codes.

CAUTION:Neverconnectpro- pane/LP fireplace directly to the propane/LPsupply.Thisfireplace requires an external regulator (notsupplied).Installtheexternal regulator between the fireplace and propane/LP supply.

119305-01A

www.desatech.com

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents VSGF36NTB, VSGF36PTB, VSGF36NRB and VSGF36PRB What to do if YOU Smell GASSafety Information Table of ContentsSafety Information Local Codes Product Identification Product FeaturesUnpacking Locating Firebox Product SpecificationsPlanning Providing Adequate Ventilation Air For Combustion VentilationUnusually Tight Construction Confined and Unconfined SpaceDetermining if You Have a Confined or Unconfined Space Determining FRESH-AIR Flow for Heater LocationVentilation AIR InstallationVentilation Air From Inside Building Ventilation Air From OutdoorsMinimum Wall and Ceiling Clearances see Installation ClearancesMantel Clearances for Built-In Installation Built-In Firebox InstallationFront Width Depth Rough Opening Dimensions for Built-in InstallationOptional Accessory Mantels Installing Firebox UsingInstalling Gas Piping to Fireplace Location Natural Gas Installation Items NeededPropane/LP Checking Gas Connections, Connecting Fireplace to Gas SupplyChecking GAS Connections Pressure Testing Fireplace Gas ConnectionsKPa Test Pressures Equal To or Less Than Psig 3.5 kPaMiddle Right Log Middle Left Log Installing LogsInstalling Fireplace Hood and Screen Hard-wiring FireboxOperating Fireplace For Your Safety Read Before LightingThermostat Models Lighting InstructionsRemote Control Models Manual Lighting ProcedureThermostat Control Operation To Turn OFF GASSet flame adjustment knob to any level between HI and LO To Turn OFF GAS To Appliance Blower OperationOptional Hand-Held Remote OperationThermostat Series Model hrc200 On/Off Series Model HRC100Inspecting Burners Key Pad Lock FeaturePilot Flame Pattern Main burnerBurner Injector Holder Pilot Air Inlet Hole Cleaning MaintenanceSpecifications Wiring Diagram Replacement PartsTechnical Service Service HintsObserved Problem Possible Cause Remedy TroubleshootingMaintenance, See Cleaning and Mainte Shut off gas supply Do not try to light any appliance Accessories Models VSGF36PTB, VSGF36NTB Illustrated Parts BreakdownParts List Models VSGF36PRB, VSGF36NRB Parts List Models VSGF36PTB, VSGF36NTB, VSGF36PRB and VSGF36NRB KEY NO. Part no Description 119305-01A 119305-01A Keep this Warranty Warranty InformationLimited Warranty VENT-FREE GAS Fireplace System
Top Page Image Contents