Frymaster FPHD manual Capillary tube cannot be repositioned

Page 22

HIGH EFFICIENCY DECATHLON SERIES GAS FRYERS

CHAPTER 1: SERVICE PROCEDURES

1.7.4 Replacing the High-limit Thermostat (cont.)

8.Mark and disconnect wires at the high-limit in the component box.

Mark and disconnect high-limit wiring (arrows). Reconnect wires to the same terminals on the replacement high-limit.

9.Remove high-limit from fryer by pulling the capillary tube and bulb through the component box opening (arrow). This may require removal of the control panel frame.

10.Reverse the above steps for high-limit installation.

IMPORTANT: When installing new high-limit, Component box opening (arrow). ensure the capillary tube and bulb are positioned

properly with the mounting hardware installed prior to tightening the compression nut. Once tightened, the

capillary tube cannot be repositioned.

1-17

Image 22

Contents Includes HD63/Red Robin and Common Cabinetry Hour Service HotlineMAY Page Computers FCC Table of Contents Page Functional Description GAS Information Altitudes of 2000 feet or lessPilot System Configuration Electronic Ignition ConfigurationControl Options Interface BoardsThermatron Board P/N Interface Boards Test Meter Setting Pins Test Results Indicates power from 12V transformerAccessing Fryers for Servicing ThermostatsRestraints Cleaning the Gas Valve Vent Tube if applicable Adjusting Burner Manifold Gas PressureMain Pilot Adjusting the Pilot FlameCalibrating the Thermatron Trailing PilotReplacing Fryer Components Replacing the ComputerReplacing the Temperature Probe Computer-equipped Fryers Replacing the Temperature Probe Computer-equipped Fryers Probe cannot be repositioned Installing the New Temperature Probe Replacing the High-limit ThermostatLocate the high-limit probe Capillary tube cannot be repositioned Replacing Rocker Switches Figure BReplacing Rocker Switches Replacing the Pilot Assembly Replacing the FrypotRemoving the joiner strip Removing gas manifold shield Removing bolts arrows securing flue to frypot Nut Valve Boot Clamp Remove the drain valve nut and attached Hardware Cutting frypot seal prior to frypot removal Lifting frypot from fryer Troubleshooting and Problem Isolation Ignition FailureElectronic Circuits Improper Burner FunctionImproper Burner Function Improper Temperature Control Improper Computer Function Improper Filtration Function Frypot Leakage Improper Basket Lift Function Bell-Crank Basket Lifts Troubleshooting Guides ProblemNot possible High Efficiency Decathlon, Thermatron with Constant Pilot Wiring DiagramsRight/left sides are the same Computer with Constant Pilot CM4-S Wiring Dean Oil Return Wiring Dean Oil Return Wiring, with Solenoid Probe Resistance Charts High Efficiency Decathlon Series GAS Fryers Parts List High Efficiency Decathlon HD Primary ComponentsSee Orifices, Section Decathlon HD50 Primary Components includes Scfhd unitsSee Drain Manifold Components, Section Decathlon HD50 Primary Components includes Scfhd units Decathlon HD60 Primary Components includes Scfhd units 823-4692Flue Box Assembly also used on HD63 fryers Front, Flue Box Decathlon FPHD65 Primary Components Cabinet Upper Back Channel, Base 265 465 565Cabinet Lower Back Door Assembly, with Liner also used for HD63 fryers Natural Orifices OrificesPropane Orifices Control Panels Control Panel Options, Joiner Strips, and AccessoriesAccessories Joiner StripsOptional Components and Controllers Bezels HD/SCFHD50 SCFHD456 SCFHD60Interface Boards High Efficiency Decathlon Series GAS Fryers Parts List Drain Valve Assembly, 1 1 ⁄ 2 with Microswitch Drain Valve Assembly, 1 1 ⁄ 2 without MicroswitchFlush Oil Drain Line Oil Return Manifold Components Oil Return Manifold Components Oil Return Manifold Components Oil Return and Oil Flush Components Suction Manifold Assembly Microswitch Bracket Assembly, Oil ReturnOil Suction Assembly Oil Suction Start FittingDescription Filtration Components SCFHD60 and SCFHD63 Series Fryers 106-7543Filtration Components FPHD65 Series Fryers Basket Lift Components Basket Lift Components Trough, Holster, & Cover Components Fasteners Screws, Nuts, Bolts Service Hotline