Frymaster FPHD manual Lifting frypot from fryer

Page 32

HIGH EFFICIENCY DECATHLON SERIES GAS FRYERS

CHAPTER 1: SERVICE PROCEDURES

1.7.8Replacing the Frypot (cont.)

26.Ensure wires and tubes will not be caught on the frypot when it is removed.

27.Remove frypot from fryer by lifting up and out.

28.Position the frypot upside down on a suitable work surface.

Lifting frypot from fryer.

29.Record position of the valve stem in relation to the frypot prior to removing the drain valve. If equipped, remove microswitches and mounting hardware from valve prior to removal. Using a suitable wrench, remove the drain valve from the frypot. Use Loctite PST567 sealant when installing drain valve on replacement frypot.

30.Remove all other hardware accessories from the frypot.

Removing drain valve from frypot.

and

31.Reverse the above steps to install the replacement frypot.

32.Add a bead of silicon around the edges of the new frypot, sealing the seam where the frypot and the cabinet meet. Only do this when the frypot is completely installed.

1-27

Image 32

Contents MAY Hour Service HotlineIncludes HD63/Red Robin and Common Cabinetry Page Computers FCC Table of Contents Page Functional Description GAS Information Altitudes of 2000 feet or lessPilot System Configuration Electronic Ignition ConfigurationControl Options Interface BoardsThermatron Board P/N Interface Boards Test Meter Setting Pins Test Results Indicates power from 12V transformerAccessing Fryers for Servicing ThermostatsRestraints Cleaning the Gas Valve Vent Tube if applicable Adjusting Burner Manifold Gas PressureAdjusting the Pilot Flame Calibrating the ThermatronMain Pilot Trailing PilotReplacing Fryer Components Replacing the ComputerReplacing the Temperature Probe Computer-equipped Fryers Replacing the Temperature Probe Computer-equipped Fryers Probe cannot be repositioned Installing the New Temperature Probe Replacing the High-limit ThermostatLocate the high-limit probe Capillary tube cannot be repositioned Replacing Rocker Switches Figure BReplacing Rocker Switches Replacing the Pilot Assembly Replacing the FrypotRemoving the joiner strip Removing gas manifold shield Removing bolts arrows securing flue to frypot Nut Valve Boot Clamp Remove the drain valve nut and attached Hardware Cutting frypot seal prior to frypot removal Lifting frypot from fryer Troubleshooting and Problem Isolation Ignition FailureElectronic Circuits Improper Burner FunctionImproper Burner Function Improper Temperature Control Improper Computer Function Improper Filtration Function Frypot Leakage Improper Basket Lift Function Bell-Crank Basket Lifts Troubleshooting Guides ProblemNot possible Right/left sides are the same Wiring DiagramsHigh Efficiency Decathlon, Thermatron with Constant Pilot Computer with Constant Pilot CM4-S Wiring Dean Oil Return Wiring Dean Oil Return Wiring, with Solenoid Probe Resistance Charts High Efficiency Decathlon Series GAS Fryers Parts List High Efficiency Decathlon HD Primary ComponentsSee Drain Manifold Components, Section Decathlon HD50 Primary Components includes Scfhd unitsSee Orifices, Section Decathlon HD50 Primary Components includes Scfhd units Decathlon HD60 Primary Components includes Scfhd units 823-4692Flue Box Assembly also used on HD63 fryers Front, Flue Box Decathlon FPHD65 Primary Components Cabinet Lower Back Channel, Base 265 465 565Cabinet Upper Back Door Assembly, with Liner also used for HD63 fryers Propane Orifices OrificesNatural Orifices Control Panel Options, Joiner Strips, and Accessories AccessoriesControl Panels Joiner StripsOptional Components and Controllers Bezels HD/SCFHD50 SCFHD456 SCFHD60Interface Boards High Efficiency Decathlon Series GAS Fryers Parts List Flush Oil Drain Line Drain Valve Assembly, 1 1 ⁄ 2 without MicroswitchDrain Valve Assembly, 1 1 ⁄ 2 with Microswitch Oil Return Manifold Components Oil Return Manifold Components Oil Return Manifold Components Oil Return and Oil Flush Components Microswitch Bracket Assembly, Oil Return Oil Suction AssemblySuction Manifold Assembly Oil Suction Start FittingDescription Filtration Components SCFHD60 and SCFHD63 Series Fryers 106-7543Filtration Components FPHD65 Series Fryers Basket Lift Components Basket Lift Components Trough, Holster, & Cover Components Fasteners Screws, Nuts, Bolts Service Hotline