Frymaster FPHD manual Removing bolts arrows securing flue to frypot

Page 28

HIGH EFFICIENCY DECATHLON SERIES GAS FRYERS

CHAPTER 1: SERVICE PROCEDURES

1.7.8 Replacing the Frypot (cont.)

12.Remove screws securing flue to frypot (access from above; a nut-driver with an extension or long screwdriver is required). Retrieve any screws dropped into the flue during removal of the flue cap and frypot bracket.

Removing bolts (arrows) securing flue to frypot.

13.Remove the clevis clip and oil return handle rod from the oil return valve at the rear of the fryer. Slip Section A of the clevis clip off of the oil return handle by pulling up on the rings. Slide the oil return handle out of the bracket and Section B of the clevis clip. Repeat for the drain flush handle (if applicable).

14.Loosen the two screws on the front of the oil return handle bracket at the front of the fryer. Remove the bracket and handle and set aside for reassembly. Repeat for the drain flush handle (if applicable).

Disconnect oil-return handle from clevis clip and valve.

Oil-return handle bracket and screws.

1-23

Image 28

Contents Includes HD63/Red Robin and Common Cabinetry Hour Service HotlineMAY Page Computers FCC Table of Contents Page Functional Description GAS Information Altitudes of 2000 feet or lessPilot System Configuration Electronic Ignition ConfigurationControl Options Interface BoardsThermatron Board P/N Interface Boards Test Meter Setting Pins Test Results Indicates power from 12V transformerAccessing Fryers for Servicing ThermostatsRestraints Cleaning the Gas Valve Vent Tube if applicable Adjusting Burner Manifold Gas PressureAdjusting the Pilot Flame Calibrating the ThermatronMain Pilot Trailing PilotReplacing Fryer Components Replacing the ComputerReplacing the Temperature Probe Computer-equipped Fryers Replacing the Temperature Probe Computer-equipped Fryers Probe cannot be repositioned Installing the New Temperature Probe Replacing the High-limit ThermostatLocate the high-limit probe Capillary tube cannot be repositioned Replacing Rocker Switches Figure BReplacing Rocker Switches Replacing the Pilot Assembly Replacing the FrypotRemoving the joiner strip Removing gas manifold shield Removing bolts arrows securing flue to frypot Nut Valve Boot Clamp Remove the drain valve nut and attached Hardware Cutting frypot seal prior to frypot removal Lifting frypot from fryer Troubleshooting and Problem Isolation Ignition FailureElectronic Circuits Improper Burner FunctionImproper Burner Function Improper Temperature Control Improper Computer Function Improper Filtration Function Frypot Leakage Improper Basket Lift Function Bell-Crank Basket Lifts Troubleshooting Guides ProblemNot possible High Efficiency Decathlon, Thermatron with Constant Pilot Wiring DiagramsRight/left sides are the same Computer with Constant Pilot CM4-S Wiring Dean Oil Return Wiring Dean Oil Return Wiring, with Solenoid Probe Resistance Charts High Efficiency Decathlon Series GAS Fryers Parts List High Efficiency Decathlon HD Primary ComponentsSee Orifices, Section Decathlon HD50 Primary Components includes Scfhd unitsSee Drain Manifold Components, Section Decathlon HD50 Primary Components includes Scfhd units Decathlon HD60 Primary Components includes Scfhd units 823-4692Flue Box Assembly also used on HD63 fryers Front, Flue Box Decathlon FPHD65 Primary Components Cabinet Upper Back Channel, Base 265 465 565Cabinet Lower Back Door Assembly, with Liner also used for HD63 fryers Natural Orifices OrificesPropane Orifices Control Panel Options, Joiner Strips, and Accessories AccessoriesControl Panels Joiner StripsOptional Components and Controllers Bezels HD/SCFHD50 SCFHD456 SCFHD60Interface Boards High Efficiency Decathlon Series GAS Fryers Parts List Drain Valve Assembly, 1 1 ⁄ 2 with Microswitch Drain Valve Assembly, 1 1 ⁄ 2 without MicroswitchFlush Oil Drain Line Oil Return Manifold Components Oil Return Manifold Components Oil Return Manifold Components Oil Return and Oil Flush Components Microswitch Bracket Assembly, Oil Return Oil Suction AssemblySuction Manifold Assembly Oil Suction Start FittingDescription Filtration Components SCFHD60 and SCFHD63 Series Fryers 106-7543Filtration Components FPHD65 Series Fryers Basket Lift Components Basket Lift Components Trough, Holster, & Cover Components Fasteners Screws, Nuts, Bolts Service Hotline