Frymaster
E4
manual
Component Wiring Standard Fryers
Probe Resistance Chart
Component Wiring Fast Ready
Contactor Delta Configuration
BINDING/JAMMING Problems
Diagnostic LED Legend
Accessories
Basket Lift Service Procedures
Replacing a Temperature Probe
Hour Service Hotline
Page 24
1.13.2
Component Wiring
1.13.2.1
Standard Fryers
1-19
Page 23
Page 25
Image 24
Page 23
Page 25
Contents
Hour Service Hotline
RE Series Electric Fryers
Page
Electrical Power Specifications
RE Series E4 Electric Fryers Table of Contents
RE Series E4 Electric Fryers
General
Replacing a Controller
Replacing Component Box Components
Removing the Control Panel Frame and Top Cap Assembly
Replacing a Temperature Probe
Replacing a High-Limit Thermostat
Page
Replacing a Heating Element
Replacing Contactor Box Components
Replacing a Frypot
Page
Right
Sediment Particle Oil Flow Up for reverse Down for forward
Disconnect flexlines indicated by the arrows
Basket Lift Service Procedures
Replacing the Filter Transformer or Filter Relay
BINDING/JAMMING Problems
Motor and Gear Problems
Interface Board Diagnostic Chart
Diagnostic LED Legend
Probe Resistance Chart
Probe Resistance Chart
Wiring Diagrams Modular Basket Lift Wiring Diagram
Modular Basket Lift Wiring Diagram
Component Wiring Standard Fryers
Component Wiring- Fryer and Half
Tilt Switch Wiring Standard Fryer and half
Component Wiring Fast Ready
Fast Ready Computer Wiring
Computer Harness Fast Ready
Control Wiring Fast Ready
Contactor Delta Configuration
Fryer and Half Wiring
Contactor Box WYE Configuration Export
Terminal Block Wiring
Oil Disposal Wiring
Wiring
13.12
Simplified RE14/17/22
Series Full Vat
Simplified RE14/17/22 Series Dual Vat Wiring
Electric RE14/17/22 Series FULL-VAT Export
13.14
Simplified RE14/17/22 Series Dual Vat Wiring Export WYE
Simplified RE14/17/22 Series Full Vat Wiring Epri
Simplified RE14/17/22 Series Full Vat Wiring Epri Export WYE
RE Series E4 Electric Fryers Parts List
Accessories
Basket Lift Assembly and Associated Parts
106-1805SP
Page
Single Station Fryer CRS Use 230-0422 for Stainless Steel
Bezel, One-Controlleruse 230-1953 for Fryer ½
Cabinets, Bases, Braces, and Associated Parts
Component
See next section for Drain Valves
Euro-Look Drain Tube Sections and Associated Parts
PART# Component
Single Footprint Full-Vat Drain Valve Assembly 106-6300
Full-Vat Drain Valve Assembly Fryer ½ Compression Washers
Page
Drain Valves and Assoc. Parts Units with Built-In Filtration
Valve, 1.25-inch Non-Filter Full-Vat Drain
Electronics and Wiring Components 2.5.1 Component Boxes
Component Boxes
Page
807-2283 Contactor, 24V
Page
807-2283 Contactor
Fuse Boxes
Cover, RH Fuse Box Used on Single Station Fryers also
Terminal Blocks
Page
Wire harnesses must
2-30 for wire
Heating Element Assemblies and Associated Parts
Be replaced when
Element Tube Assemblies
Controllers
Wiring Contactor Box Wiring Assemblies 12-Pin Dual-Vat C-1
Contactor Box Wiring Assemblies 12-Pin Full-Vat C-1
Contactor Box Wiring Assemblies 6-Pin Left Element
Contactor Box Wiring Assemblies 9-Pin Right Element
Main Wiring Harnesses Full and Dual Vat
Main Wiring Harnesses Fryer and ½
Component Box, Filter Pump and Basket Lift Wiring Harnesses
Page
Filtration System Components
Roller Kit includes 4 rollers, 4 nuts and 4 lock washers
√ Recommended parts
Frypot Assemblies and Associated Parts
Frypot Assembly does not include Item
Oil Return System Components
Typical Rear-Flush Oil Return Plumbing
Oil Return System Components
Oil Disposal Plumbing
Oil Disposal Wand
Wiring Connectors and Pin Connectors
Fasteners
Service Hotline
Related manuals
Manual
2 pages
51.67 Kb
Manual
36 pages
37.47 Kb
Manual
78 pages
9.63 Kb
Top
Page
Image
Contents