Troy-Bilt RZT manual MANUFACTURER’S Warranty Coverage

Page 35

CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT

YOUR WARRANTY RIGHTS AND OBLIGATIONS

The California Air Resources Board and MTD Consumer Group Inc are pleased to explain the evaporative emission control system warranty on your 2007 lawn mower. In California, new lawn mower must be designed, built and equipped to meet the State’s stringent anti-smog standards. MTD Consumer Group Inc must warrant the EECS on your lawn mower for the period of time listed below provided there has been no abuse, neglect or improper maintenance of your lawn mower.

Your EECS may include parts such as the carburetor, fuel-injection system, the ignition system, catalytic converter, fuel tanks, fuel lines, fuel caps, valves, canisters, filters, vapor hoses, clamps, connectors, and other associated emission-related components.

Where a warrantable condition exists, MTD Consumer Group Inc will repair your lawn mower at no cost to you including diagnosis, parts and labor.

MANUFACTURER’S WARRANTY COVERAGE:

This evaporative emission control system is warranted for two years. If any evaporative emission-related part on your equipment is defective, the part will be repaired or replaced by MTD Consumer Group Inc.

OWNER’S WARRANTY RESPONSIBILITIES:

As the lawn mower owner, you are responsible for performance of the required maintenance listed in your owner’s manual. MTD Consumer Group Inc recommends that you retain all receipts covering maintenance on your lawn mower, but MTD Consumer Group Inc cannot deny warranty solely for the lack of receipts.

As the lawn mower owner, you should however be aware that MTD Consumer Group Inc may deny you warranty coverage if your lawn mower or a part has failed due to abuse, neglect, or improper maintenance or unapproved modifications.

You are responsible for presenting your lawn mower to MTD Consumer Group Inc’s distribution center or service center as soon as the problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have a question regarding your warranty coverage, you should contact the MTD Consumer Group Inc Service Department at 1-800-800-7310.

GENERAL EMISSIONS WARRANTY COVERAGE:

MTD Consumer Group Inc warrants to the ultimate purchaser and each subsequent purchaser that the lawn mower is: Designed, built and equipped so as to conform with all applicable regulations; and free from defects in materials and workmanship that cause the failure of a warranted part to be identical in all material respects to that part as described in MTD Consumer Group Inc’s application for certification.

The warranty period begins on the date the lawn mower is delivered to an ultimate purchaser or first placed into service. The warranty period is two years.

Subject to certain conditions and exclusions as stated below, the warranty on emission-related parts is as follows:

1.Any warranted part that is not scheduled for replacement as required maintenance in the written instructions supplied, is warranted for the warranty period stated above. If the part fails during the period of warranty coverage, the part will be repaired or replaced by MTD Consumer Group Inc according to subsec- tion (4) below. Any such part repaired or replaced under warranty will be warranted for the remainder of the period.

2.Any warranted part that is scheduled only for regular inspection in the written instructions supplied is warranted for the warranty period stated above. Any such part repaired or replaced under warranty will be warranted for the remaining warranty period.

3.Any warranted part that is scheduled for replacement as required maintenance in the written instructions supplied is warranted for the period of time before the first scheduled replacement date for that part. If the part fails before the first scheduled replacement, the part will be repaired or replaced by MTD Consumer Group Inc according to subsection (4) below. Any such part repaired or replaced under warranty will be warranted for the remainder of the period prior to the first scheduled replacement point for the part.

4.Repair or replacement of any warranted part under the warranty provisions herein must be performed at a warranty station at no charge to the owner.

5.Notwithstanding the provisions herein, warranty services or repairs will be provided at all of our distribution centers that are franchised to service the subject engines or equipment.

6.The lawn mower owner will not be charged for diagnostic labor that is directly associated with diagnosis of a defective, emission-related warranted part, provided that such diagnostic work is performed at a warranty station.

7.MTD Consumer Group Inc is liable for damages to other engine or equipment components proximately caused by a failure under warranty of any warranted part.

8.Throughout the lawn mower warranty period stated above, MTD Consumer Group Inc will maintain a supply of warranted parts sufficient to meet the expected demand for such parts.

9.Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge to the owner. Such use will not reduce the warranty obligations of MTD Consumer Group Inc.

10.Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any non-exempted add-on or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims. MTD Consumer Group Inc will not be liable to warrant failures of warranted parts caused by the use of a non-exempted add-on or modified part.

WARRANTED PARTS:

The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from such warranty coverage if MTD Consumer Group Inc demonstrates that the lawn mower has been abused, neglected, or improperly maintained, and that such abuse, neglect, or improper maintenance was the direct cause of the need for repair or replacement of the part. That notwithstanding, any adjustment of a component that has a factory installed, and properly operating, adjustment limiting device is still eligible for warranty coverage. The following emission warranty parts list are covered: Fuel Line, Fuel Line Clamps

Page 34 Page 36
Image 35
Page 34 Page 36
Contents Operator’s Manual Record Product Information Table of ContentsTo The Owner Thank YouCalifornia Proposition General Operation Important Safe Operation PracticesDo Not Slope OperationTowing ServiceGeneral Service ChildrenAverage Useful Life Do not modify engineSpark Arrestor Safe Operation Practices  Tractor preparation Assembly & Set-UpContents of Crate Clevis Pin Internal Cotter Pin Notch Connect the BatteryPosition Rear Bumper Lower Deck Discharge Chute DeflectorRH and LH Drive Control Levers Deck Height IndexDeck Lift Handle Hour Meter / Indicator Panel Ignition SwitchPower Take-Off PTO Switch Seat Adjustment Lever Not SeenParking Brake Engagement Lever Indicator Panel FeaturesThrottle Control Choke ControlBefore Operating Your Tractor General SafetySafety Interlock System OperationParking Brake Using Jumper Cables To Start EngineStarting the Engine Cold Weather StartingDriving the Tractor Forward Stopping the EnginePractice Operation Initial Use Driving the TractorTurning While Driving Rearward Driving the Tractor In ReverseExecuting a Zero Turn Stopping the TractorDriving On Slopes Operating The Pto Using the Mower DeckChecking the Safety Interlock Circuits Pull the PTO switch upward to the Engaged positionBattery Maintenance MaintenanceAir Cleaner Spark Plug Hydrostatic Transmission General Battery InformationUsing the Transmission Bypass Rods Tire MaintenanceUsing the Deck Wash System Cleaning the Spindle PulleysEmptying the fuel system Battery StorageUsing a fuel stabilizer Tractor StorageRemoving The Tractor From Storage AdjustmentsAdjusting RH & LH Drive Control Levers Adjusting the Operators SeatRefer to Figure Leveling the Mower DeckSide to Side Leveling Front to Back LevelingAdjusting the Gauge Wheels Replace Air Filter Element Maintenance ScheduleCheck Engine Oil Level Servicing Electrical System ServiceBattery Removal Charging the BatteryBracket Slot Deck InstallationRolling the belt off the PTO pulley SupportRolling the belt into the PTO pulley Using the idler pulley to tension the beltReplacing the Deck Drive Belt Blades may be removed as follows Mower Blade CareTransmission Drive Belt Console Jam Nut Stop Bolt Tractor CreepingTractor High Speed Tracking Problem Cause Remedy TroubleshootingKohler Fuel Filter Component Part Number and Description759-3336 Spark Plug Champion RC12YC KH-12-050-01-S Kohler Oil FilterPart Number and Description Component590-303-000 Double Bagger 190-193-000 Mulch Plug Attachments & AccessoriesModel Number Description MANUFACTURER’S Warranty Coverage MANUFACTURER’S Limited Warranty for Manual del operador Registro de información de producto Al propietarioGracias ÍndiceFuncionamiento general Medidas importantes de seguridadProposición 65 de California No haga lo siguiente Funcionamiento en pendientesHaga lo siguiente Manejo seguro de la gasolina ServicioNiños RemolqueVida útil media No modifique el motorAviso referido a emisiones Amortiguador de chispasSección 2 Medidas de seguridad  Instale el asiento del operador Montaje y ConfiguraciónContenido del cajón Preparación del tractorDel borne sobre el borne negativo de la batería Conecte la bateríaColoque el paragolpes trasero en posición Baje el deflector del canal de descarga de la plataformaManija de elevación de la plataforma Controles y CaracterísticasPosicionamiento de la altura de la plataforma Bandeja de almacenamiento Interruptor de encendidoVarilla de derivación de la transmisión no se ve PortacubetaParagolpes trasero no se muestra Control del reguladorControl del cebador Palanca de enganche del freno de manoSistema de bloqueo de seguridad FuncionamientoSeguridad general Antes de hacer funcionar el tractorUso de cables de puente para arrancar el motor Encendido del motorArranque del motor en clima frío Conducción del tractor Detención del motorPractique el modo de operación con el tractor uso inicial Conducción del tractor en marcha atrás PosiciónNeutralMás despacio Giro con el tractor en marcha directaGiro de radio cero Detención del tractorOperación en pendientes Control de los circuitos de bloqueo de seguridad Funcionamiento de la potencia de arranque PtoUso de la plataforma de la cortadora Mantenimiento Uso del sistema de lavado de la plataforma Mantenimiento de la bateríaMantenimiento de los neumáticos LubricaciónUso de un estabilizador de combustible Almacenamiento de la bateríaAlmacenamiento del tractor Si guarda el tractor por 30 días o másAjuste del asiento del operador AjustesTuercaOuterhexagonal De la platafor maTornillo HexagonalTuerca de Seguridad Ajuste de las ruedas de calibraciónReborde Tuer ca deCalendario de mantenimiento Carga de la batería ServicioRetiro de la batería Mantenimiento del sistema eléctricoDeslice la plataforma hacia adelante de modo que la Instalación de la plataformaCorr‘V’ Bealt en V Tire de la polea loca TransmisiónTube Reemplazo de la correa de transmisión de la plataformaUso de la polea loca para tensar la correa Correa de laPolea Correa de transmisiónMénsulaIdler PoleaPTO de la potenciaContratuerca Desplazamiento lento del tractorDesvío del tractor a alta velocidad Problema Causa Solución Solución de ProblemasComponente Número de pieza y Descripción Piezas de reemplazoSección 9 Piezas de reemplazo Número de modelo Descripción Aditamentos y accesoriosCobertura DE LA Garantía DEL Fabricante Garantía Limitada DEL Fabricante Para

RZT specifications

The Troy-Bilt RZT is a formidable lawn mower that brings a blend of efficiency, performance, and user-friendly features to the forefront of lawn care. Designed for homeowners who demand both power and precision, the RZT series offers a riding mower experience unlike any other.

One of the standout features of the Troy-Bilt RZT is its innovative Zero Turn Technology, which enables exceptional maneuverability. This technology allows users to make sharp turns and navigate around obstacles with ease, ensuring precise mowing in tight spaces. The dual lever steering system enhances control, allowing for quick direction changes and saving time on larger properties.

The engine options available with the RZT series range from powerful V-twin engines to reliable OHV engines, providing homeowners with choices that cater to their specific mowing requirements. These engines ensure robust performance, delivering the horsepower needed to tackle even the toughest grass and terrain.

The RZT models come equipped with reinforced deck materials that result in superior durability. The cutting deck typically ranges from 42 to 54 inches, allowing users to cover more ground in less time while achieving a clean, professional cut. Additionally, the adjustable cutting height feature provides versatility, enabling users to customize their mowing height based on grass type and conditions.

Troy-Bilt enhances user convenience with features such as an ergonomic seat design, ensuring maximum comfort during extended mowing sessions. The easy-to-access controls and dashboard simplify operation, making it suitable for both novice and experienced users alike.

Maintenance is made straightforward with Troy-Bilt’s integrated maintenance reminders and easy-to-reach grease points for routine upkeep. The mower's mulch kit option allows for grass clippings to be finely chopped and returned to the lawn, promoting a healthier turf while saving time on clean-up.

Overall, the Troy-Bilt RZT combines powerful performance, advanced technology, and practical user-focused features to create a reliable riding mower. Whether managing a suburban lawn or a larger property, the RZT series proves to be a top contender for those seeking to maintain their outdoor space efficiently and effectively.
Top Page Image Contents