Zenith C-30HDG manual Down-Hill Pumping, VerticalPumping, ValveSeats, Pulsation

Page 32

C-30HDG PUMP — OPERATING INFORMATION

Down-Hill Pumping

Downhillpumpingcanbedifficultonsomejobs.Itissuggestedthat a sponge 2”x 4”x 6” be placed in the hose before the start of pumping.Wetthespongebeforeplacingitinthehose.Reference the Operating Suggestions at the start of this section for slurry procedures.

The reason for using the wet sponge is to keep the slurry from running too far ahead of the concrete and so reducing the possibility of separation.When the pump is stopped, the material can flow slowly down, due to gravity, and cause the hose to collapse.

Whenpumpingisresumed,youcanexpectablockageatthepoint ofhosecollapse.Topreventthisfromhappening,thehosecanbe “kinked off” at the discharge end when the pump is stopped to prevent the gravity flow of the material in the hose.

The use of stiffer mixes when pumping down-hill will decrease gravity flow of the material in the hose and will assure a smoother operation between the cam roller bearing and cam plate. As with any job, make sure that the hose and the couplings are in good workable shape.

VerticalPumping

When pumping vertically up the side of a building, above 40 feet, we would recommend the installation of steel pipe securely fastened at intervals as necessary to support the pipe. Ninety degree,longradiuspipesweepsshouldbeinstalledatthetopand bottom of the steel line.

Usea25ft.hose,orshortsection,offthepump;andforthebalance of the horizontal distance to the vertical line, use steel pipe.This type of installation has been satisfactory on many jobs being pumpedinexcessof100feethigh.Linepressuresarealwaysless using steel pipe as compared to hose.

When pumping vertically using all hose, it is recommended not to go higher than 50 feet with hose.The hose should be tied off at intervals of 10 feet, if possible. Special attention should be given whentieingthehoseoffatthetopasthehosewillhaveatendency to stretch when filled with concrete.This will increase the possi- bility of a blockage at the point where the hose is tied off.To avoid this, a long radius of 90 degree elbow is recommended. The suggested place to tie off is on the hose, under the clamp.

It is strongly recommended that steel pipe be used on ALL vertical pumping for safety and conve- nience.

ValveSeats

If the volume at the end of hose starts to decrease gradually and eventuallyalmoststops,itisquitelikelythatthevalveseatshave had excessive wear and need replacement. Once they have reached a certain wear point, they may“channel out”rapidly and material will reciprocate past the ball on each stroke.

The hollow steel ball should be replaced when it starts to show dentsorappearstobebadlyworn.Sandandaggregatematerials insomeareasareextremelysharpandhardandthereforehighly abrasive.Undertheseconditionswhenpumpingstiffmixes,orto high elevations which cause line pressures, it will be noted that valve components may have short wear life.

If this condition exists, it is advisable to remove the manifold only, andinspectthelowerseatattheendofeachday.Ifitappearsthat the seat is beginning to“channel out", replace before starting the nextday’s pour.

The upper valve seat can be inspected after each washout by running your finger around lower edge of seat where the ball makescontact.Youcanreachthisfromtheinsideofthehopper.Be sure that the engine is turned off.

Pulsation

A slight pulsation of the hose will always be noticeable near the pump.Excessivepulsationofthehosenearthepumpisnormally due to higher than average line pressures caused by stiff, harsh mixes, or extremely long pumping distances.

The use of 2 -1/2” I.D. hose in these extreme cases reduces line pressures or the addition of slight amounts of water to the mix, if permissible,willpermiteasierpumping.Theuseofcertainpump- ing admixtures may help.

If excessive pulsation exists in the hose, it is advisable to use burlaporsomemeansofwearprotectionunderthehoseatpoints wherethehosemaywearthroughtheoutercover;e.g.overforms, steel or sharp curbs.

PAGE 32 — MAYCO C-30HDG PUMP — OPERATION AND PARTS MANUAL — REV. #6 (04/02/12)

Image 32
Contents Model C-30HDG 30HDG Pump Proposition 65WARNING 30HDG Pump SILICOSIS/RESPIRATORYWARNINGS Silicosis WarningTable of Contents Order via Fax Dealers Only Parts Ordering ProceduresBest Deal! Order via Internet Dealers Only 30HDG Pump Pump Specifications 30HDG Pump Specifications30HDG Pump Pump Dimensions 30HDG Concrete Pump DimensionsYou can be injured if you do not follow directions 30HDG Pump Safety Message Alert SymbolsStructure that does not provide ample free flow air Always wear approved eye and hearing protection 30HDG Pump Safety Message Alert SymbolsAlways wear approved respiratory protection 30HDG Pump Rules for Safe Operation General SafetyHigh Temperatures Allow the engine 30HDG Pump Rules for Safe Operation Do not use worn out hoses or couplings inspect dailyEmergencies Maintenance SafetyLifting Page PumpTrailer Vehicle Connection Recommended Maintenance30HDG Pump -TOWING Guidelines 30HDG Pump -TOWING Guidelines Towing Applications30HDG Pump -TRAILER Safety Guidelines Trailer Safety Precautions30HDG Pump -TRAILER Safety Guidelines Tires/Wheels/Lug NutsTiresWear/Inflation Torsion Bar Suspension30HDG Pump -TRAILER Safety Guidelines Lug Nut Torque RequirementsStart all wheel lug nuts by hand NEVER! use an pneumatic air gun to tighten wheel lug nutsPage 30HDG Pump Operation and Safety Decals Operation and Safety Decals30HDG Pump Important Hand Signals Operation Hand Signals30HDG Pump Pump Components Major Pump Components30HDG Pump Pump Components 30HDG Pump Control BOX Components Pump Control Box Components30HDG Pump Engine Components Zenith 416 Basic Engine ComponentsSample Design Mix 3000 Psi 3/8 in. Slump 4- 5 30HDG Pump General InformationPump Mix Guidelines 30HDG Pump HOW IT Works Pumping Cylinder30HDG Pump HOW IT Works Pumping Pistons30HDG Pump Operating Information Operating Suggestions30HDG Pump Operating Information New PumpsPumping Tips Mbvr air entraining, acts as a lubricantStop the pump. Switch OFF the engine Avoiding Setting of the Mix in the SystemClearing a Plugged Manifold Clearing a Mix from the SystemDown-Hill Pumping VerticalPumpingValveSeats PulsationSnap-Joint 30HDG Pump Operating InformationCam Roller Read safety instructions at the beginning of this manual 30HDG Pump InspectionBefore Starting Engine Oil CheckLubrication Box 30HDG Pump InspectionGasoline Check 30HDG Pump INSPECTION/STARTUP Checking Engine Coolant LevelIf cooling water is dirty, flush the cooling system Belt DeflectionRadio Remote Control Operation 30HDG Pump STARTUP/SHUTDOWN ProceduresRemote Control Operation 30HDG Pump Maintenance Pump Preventive MaintenanceGeneral Clean-up Procedure Always carry extra Orings30HDG Pump Maintenance Pump Sponge Clean-out ProcedureNever use compressed air to clean out the lines Piston Cup Wear30HDG Pump Maintenance Pump Crankshaft and Cam Assembly ProcedureFollowing procedure will assist you in replacing the lining Bearing Installation Bearing/Cam Bushing InstallationDetent Hole 3 Installation Detent Holes30HDG Pump Maintenance Pump Working Loads Installation and Drive AlignmentRoller Chain Application Drive Chain Lubrication Chain-Link Cross SectionInstallation Of Coversides Installation of Spring Locks and Cotter-PinsAssembling and Disassembling Drive Chain Chain-Link Pin Removal30HDG Pump Enginetroubleshooting Engine Troubleshooting30HDG Pump Enginetroubleshooting Fuel tank empty? Replace fuel filter Fuel filter clogged?Unions a required Engine oil level too full? Correct engine oil level?Example 30HDG Pump Engine Fault CodesMalfunction Indicator Diagnostic System 30HDG Pump Engine Fault Codes GCP ECU Fault Code List for ZZP 416 EngineFuel LPG or NG run-out longer than expected AUX 5V Analog Input 3 low 30HDG Pump -WIRING Diagram Zenith Wiring Harness Zenith Fuel Injection System Wiring Diagram30HDNI Pump -WIRING Diagram Zenith Wiring Harness 30HDG Pump -WIRING Diagram Wiring Diagram30HDG Pump PIN Connections ZPP 416, 420 & 640 Customer 16-PIN Connections30HDG Pump -WIRING Diagram Tail Lights TrailerTail Lights Wiring DiagramPage Appendix C-30HDNI C-30HDNI Slumptest Procedure Slump Test 2/3 FullAppendix C-30HDG Concrete MIX Information Appendix C-30HDG Concrete MIX Information 2708 27752685 2749Appendix Recommended Shotcrete System Recommended Shotcrete SystemGeneral recommendations Appendix Recommended Shotcrete Accessories Recommended Shotcrete AccessoriesAppendix Recommended Shotcrete Accessories Explanation of Code in Remarks Column Xxxxx only Not Used on30HDG Pump Suggested Spare Parts Units30HDG Pump Nameplate and Decals 30HDG Pump Nameplate and Decals 30HDG Pump Compensator Piston ROD Assy Compensator Piston ROD AssySpring Return Piston Guide AssyFitting Bearing CUP30HDG Pump Connecting ROD Drive Side Assy Connecting ROD Drive Side AssyPiston ROD Assy 30HDG Pump Rocker Assy Rocker AssyConnecting ROD Shaft Rocker ARMJournal Block Bolt 1-14X2 HEX Head30HDG Pump COUNTER-SHAFT Assy Countershaft Assy30HDG Pump COUNTER-SHAFT Assy 30HDG Pump Crankshaft Assy Crankshaft AssyLock Washer 3/4 30HDG Pump Crankshaft AssyBearing Block 30HDG Pump Manifold Assy Manifold Assy30HDG Pump Manifold Assy 30HDG Pump Frame Assy Frame AssyFrame Assembly AXLE, AssemblyJack STAND, Rear Washer Thick30HDG Pump Axle Assy Axle AssyCAP 14 Chrome Includes Items W Dust CoverCastle NUT Outer Bearing30HDG Pump MUFFLER, AIR FILTER, and Stop Switch Assy MUFFLER, AIR Filter and Stop Switch AssyPRECLEANER, AIR Filter ZE1 ELEMENT, AIR Filter Gland ConnectorStop SWITCH, Engine Cover FILTER, AIR30HDG Pump Clutch Assy Clutch AssyRotor Assembly Clutch Housing W/LININGWASHER, Lock 1/2 WASHER, Flat 1/2 Special30HDG Pump Engine Mounting Brackets Assy Engine Mounting Brackets AssySupport BRACKET, Right Support BRACKET, LeftSPACER, 20 OD X 11 ID X 32 Long BRACKET, ECU Mount30HDG Pump RADIATOR, Mounting Bracket and Hoses Assy RADIATOR, Bracket and Hoses AssyPart Name 30HDG Pump Control BOX Assy Control BOX AssySWITCH, Throttle Control Ignition SwitchCONNECTOR, Plastic Ignition Switch KEY30HDG Pump Battery Assy Battery AssyCABLE, Positive Battery BOX, BatteryCABLE, Negative Battery BATTERY, 12 Volt30HDG Pump Fueltank Assy Fuel Tank AssyHOSE, Fuel 5/16 CLAMP, HoseFILTER, Fuel Includes Item30HDG Pump Hopper Assy Hopper AssyWasher 5/8 Flat HopperPIN, Hair 30HDG Pump Hood Assy Hood AssyRivet Latch KITBUMPER, Rubber NUT 1/2-13 Heavy HEX30HDG Pump Lubrication Panel Assy Lubrication Panel AssyFITTING, Grease 1/8 NPT Straight Fitting 1/8 NPTCoupling W/NUT 1/8 NPT 1FT=1PC30HDG Pump Remote Control Cable Assy Remote Control Cable AssySWITCH, Micro Guard Switch AluminumCONNECTOR, 3/16 Ring Junction BOXTerms and Conditions of Sale Parts Freight PolicyMayco Pumpwarranty Mechanical Drive ModelsHERE’S HOW to GET Help

C-30HDG specifications

The Zenith C-30HDG is a standout in the world of gaming monitors, tailored specifically for gamers who seek both high performance and stunning visuals. This monitor excels in delivering a riveting experience, combining advanced technology with robust features that cater to the needs of competitive gamers and casual enthusiasts alike.

One of the main features of the Zenith C-30HDG is its impressive 30-inch display size, providing an immersive gaming experience with ample screen real estate. With a resolution of 2560 x 1080 pixels, this ultrawide monitor offers a 21:9 aspect ratio, which expands the field of view in games, allowing players to spot enemies and navigate expansive environments more effectively. The curved design further enhances immersion, wrapping the visuals around the viewer's peripheral vision.

Another key characteristic of the Zenith C-30HDG is its rapid 200Hz refresh rate, enabling smooth motion and reduced motion blur during high-paced gaming sessions. This feature is particularly beneficial for fast-action games, where every millisecond counts. Complementing the refresh rate is a low response time of 1ms, ensuring that ghosting effects are minimized, resulting in crisp visuals even during intense gameplay.

The monitor supports AMD FreeSync and NVIDIA G-Sync technologies, which work to eliminate screen tearing and stuttering, providing a seamless and tear-free gaming experience. Whether users are playing an action-packed shooter or an expansive role-playing game, the display's adaptive synchronization ensures that they stay fully engaged without distractions.

In terms of connectivity, the Zenith C-30HDG is well-equipped with multiple HDMI and DisplayPort inputs, making it easy to connect to a variety of devices, including gaming consoles, PCs, and laptops. This versatility caters to gamers who utilize multiple platforms for their gaming experiences.

The Zenith C-30HDG also integrates advanced color accuracy features, supporting a wide color gamut with rich and vibrant colors that bring games to life. With built-in settings for different gaming genres, users can optimize their visual experience based on the type of game they are playing.

In conclusion, the Zenith C-30HDG is a remarkable gaming monitor that offers an outstanding combination of size, resolution, and advanced technologies. Its features cater not only to competitive gamers seeking the best performance but also to casual gamers who appreciate breathtaking visuals. With the Zenith C-30HDG, gamers can elevate their experience and fully immerse themselves in their favorite worlds.