Multiquip DCA-400SSV operation manual Towing &Transporting Safety, Emergencies

Page 13

DCA-400SSV— RULES FOR SAFE OPERATION

Towing &Transporting Safety

To reduce the possibility of an accident while transporting the generator on public roads, always make sure the trailer that supports the generator and the towing vehicle are in good operating condition and both units are mechanically sound.

The following list of safety precautions should be followed when towing your generator:

CAUTION - FOLLOWTOWING REGULATIONS

Check with your local county or state safety towing regulations, in addition to meeting Department of Transportation (DOT) SafetyTowing Regulations, before towing your generator.

ALWAYS shutdown engine before transporting.

Tighten both fuel tank caps securely.

If generator is mounted on a trailer, make sure trailer complies with all local and state safety transportation laws. Follow the listed Towing & Transporting Safety guidelines for basic towing techniques.

Make sure the hitch and coupling of the towing vehicle are rated equal to, or greater than the trailer "gross vehicle weight rating.”

ALWAYS inspect the hitch and coupling for wear. NEVER tow a trailer with defective hitches, couplings, chains etc.

Check the tire air pressure on both towing vehicle and trailer. Trailer tires should be inflated to 50 psi cold. Also check the tire tread wear on both vehicles.

ALWAYS make sure the trailer is equipped with a "Safety Chain".

ALWAYS attach trailer’s safety chains to towing vehicle properly.

ALWAYS make sure the vehicle and trailer directional, backup, brake, and trailer lights are connected and working properly.

DOT Requirements include the following:

z Connect and test electric brake operation.

z Secure portable power cables in cable tray with tie wraps.

The maximum speed for highway towing is 55 MPH unless posted otherwise. Recommended off-road towing is not to exceed 15 MPH or less depending on type of terrain.

Place chock blocks underneath wheel to prevent rolling, while parked.

Use the trailer’s swivel jack to adjust the trailer height to a level position while parked.

Avoid sudden stops and starts. This can cause skidding, or jack-knifing. Smooth, gradual starts and stops will improve towing.

Avoid sharp turns.

Trailer should be adjusted to a level position at all times when towing.

Raise and lock trailer wheel stand in up position when transporting.

The maximum speed for highway towing is 55 MPH unless posted otherwise. Recommended off-road towing is not to exceed 15 MPH or less depending on type of terrain.

Place support blocks underneath the trailer’s bumper to prevent tipping, while parked.

Avoid sharp turns to prevent rolling.

DO NOT transport generator with fuel in tank.

Emergencies

ALWAYS know the location of the nearest fire extinguisher.

ALWAYS know the location of the nearest and first aid kit.

ALWAYS know the location of the nearest phone or keep a phone on the job site, in case of emergencies.

ALWAYS have easy access to the phone numbers of the nearest Ambulance, Doctor and Fire Department. This information will be invaluable in the case of an emergency.

DCA-400SSV— OPERATION AND PARTS MANUAL — REV. #0 (04/19/06) — PAGE 13

Image 13 Contents
Model DCA-400SSV Parts List NO. C38713010042 DCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 Wilmington Ave Carson, CA Heres HOW to GET HelpTable of Contents When ordering parts Please supply the following information Parts Ordering ProceduresDCA-400SSV- Specifications DCA-400SSV- Dimensions TOP, Side and Front You can be injured if you do not follow directions DCA-400SSV- Safety Message Alert Symbols This generator, other property, or DCA-400SSV- Safety Message Alert SymbolsDCA-400SSV- Rules for Safe Operation General SafetyGenerator Grounding Electrical SafetyBattery Safety Maintenance SafetyEmergencies Towing &Transporting SafetyGenerator Decals DCA-400SSV- Generator DecalsGenerator Decals Cont inued DCA-400SSV- Generator DecalsTypical Generator Grounding Application DCA-400SSV- InstallationIndoor Installation Outdoor InstallationWhen connecting the generator MountingEngine Operating Panel GeneratorGenerator Control Panel Output Terminal PanelMajor Components DCA-400SSV- Major ComponentsPilot Lamp Indicates DCA-400SSV- Generator Control PanelAuto On/Off Engine Controller Mpec DCA-400SSV- Generator Control Panel DCA-400SSV- Engine Operating Panel DCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 Output Terminal Familiarization DCA-400SSV- Output Terminal Panel FamiliarizationF.C.I. Receptacle 120VAC Gfci ReceptaclesOver Current Relay Connecting LoadsThree Phase Load Single Phase LoadDCA-400SSV- Load Application Motors and motor-drivenVoltage Change-Over Board Generator OutputVoltagesGenerator Amperage Change-Over Switch How to Read the Output Terminal GaugeDCA-400SSV- Generator OUTPUTS/ Gauge Reading Maximum AmpsUvwo Terminal Output Voltages DCA-400SSV- Output Terminal Panel Connections3Ø-240V Uvwo Terminal Output Voltages 1Ø-240V Uvwo Terminal Output Voltages1Ø-480V Uvwo Terminal Output Voltages 3Ø-480V Uvwo Terminal Output Voltages1Ø-277V Uvwo Terminal Output Voltages Circuit Breakers DCA-400SSV- PRE-SETUPLubrication Oil Fuel CheckRefueling Refueling ProcedureAir Cleaner Fan Belt Tension Cleaning the RadiatorCoolant Antifreeze/Summer Coolant/Water Operation FreezingWeatherBattery Cable Installation BatteryWiring AlternatorBefore Starting Place the engine speed switch in the LOW down positionEngines exhaust contains harmful emissions Direct exhaust away from nearby personnelNo Load Coolant Temperature GaugePlace the engine speed switch in the High position Starting Auto ModePlace the Mpec Control Switch in the Auto position Emergency Shutdown Procedure Normal Shutdown ProcedureGeneral Inspection Air Cleaner DCA-400SSV- MaintenanceAir Cleaner with Dust Indicator Air filter should not beCleaning Inside the Fuel Tank Service DailyCleaning the Fuel Strainer Fuel AdditionAir Removal Radiator CleaningCheck Oil Level Replacing Oil FilterTo ensure adequate starting Battery Charger JacketWater Heater Power ConnectionsTrailer Maintenance DCA-400SSV-TRAILER MaintenanceCoupler Type of hitch used on the trailer for towing Brake Adjustment DCA-400SSV-TRAILER MaintenanceBrakes Check the wheel and drum for free rotationTireWear/Inflation Tires/Wheels/Lug NutsSuspension Start all wheel lug nuts by hand Lug Nut Torque RequirementsDCA-400SSV-TRAILERWIRING Diagram DCA-400SSV- Generatorwiring Diagram DCA-400SSV Enginewiring Diagram S/N 3722759 and below DCA-400SSV Enginewiring Diagram S/N 3722760 and Above Generator Troubleshooting DCA-400SSV-TROUBLESHOOTING GeneratorDCA-400SSV-TROUBLESHOOTING Engine Controller Example Error Code DCA-400SSV-TROUBLESHOOTING Diagnostic LampMethod of Operation For a complete understandingDCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 DCA-400SSV- Explanation of Code in Remarks Column Sample Parts ListRING, SENSOR, Coolant Temp Part number on this Suggested Spare Parts listSensor OIL, Pressure & Temp RING, Sensor OIL, Pressure & TempGenerator Assy DCA-400SSV- Generator AssyRotor Assy Field Assy Balancing Weight KITResistor 80W 300K RECTIFIER, RM50TC-24Generator ASSY. DCA-400SSV- Generator ASSY.Coupling Adapter Suction CoverSPACER, Bearing BEARING, 6208ZZEngine Operating Panel Assy DCA-400SSV- Engine Operating Panel AssyAlarm Lamp Engine Speed SwitchCOVER, AIR Cleaner Operating PanelControl BOX Assy DCA-400SSV- Control BOX AssySwitch Bracket TIMER, DC/AC24VControl BOX Circuit BREAKER, 1000AControl BOX ASSY. DCA-400SSV- Control BOX ASSY.DCA-400SSV- Control BOX ASSY. Engine and Radiator Assy DCA-400SSV- Engine and Radiator AssyConnector AIR CLEANER, CompleteIncludes Items W Engine Foot70 DCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 GASKET, OIL Temperature SENSOR, OIL TemperaturePlug RingOutput Terminal Assy DCA-400SSV- Outputterminal AssyCircuit BREAKER, 20A Output TerminalCircuit BREAKER, 50A BRACKET, Circuit BreakerBattery Assy DCA-400SSV- Battery AssyBattery Sheet BatteryBattery Band Battery BoltMuffler Assy DCA-400SSV- Muffler AssyExhaust Pipe MufflerSeal Clamp Fuel Tank Assy DCA-400SSV- Fueltank AssyCAP, Fuel Tank Fuel TankKEY Fuel FilterEnclosure #1 Assy DCA-400SSV- Enclosure #1 AssyFloor Panel BaseFront Frame LiningDCA-400SSV- Enclosure #2 Assy Louver Panel Rear FrameCOVER, Rear Frame Duct CoverEnclosure #2 ASSY. DCA-400SSV- Enclosure #2 ASSY.STOPPER, Door StayHinge StopperEnclosure #3 Assy DCA-400SSV- Enclosure #3 AssySide Panel Splasher PanelDuct Side DoorDCA-400SSV- Enclosure #3 ASSY. C3454303104 387515130419A C3494409804 C3454303204Rubber Seals Assy DCA-400SSV- Rubber Seals Assy0228901075 02289013900228900825 0228901410Nameplate and Decals Assy DCA-400SSV- Nameplate and Decals AssyControl BOX Group Name Plate AssyEngine & Radiator Group Engine Operating Panel Group94 DCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 Name Plate and Decals Assy Battery GroupMuffler Group Fuel Tank GroupTerms and Conditions of Sale Parts DCA-400SSV- Operation and Parts Manual REV. #0 04/19/06 Your Local Dealer is
Related manuals
Manual 96 pages 7.79 Kb