Land Pride Essential Lubrication and Fluid Maintenance for Models 720 and 220
Page 38

 

Table of Contents

Section 7 Lubrication and Fluids

 

 

 

 

 

Transmission Fluid

 

Warm oil drains quickly and completely. Drain used oil

Transmission lubrication is essential and must be

while it is still warm as follows:

 

maintained to ensure long life of the transmission. It is extremely important to use proper fluid. Also, it is important to check and change oil as outlined in the maintenance schedule below.

NOTE: Running vehicle low on transmission oil can damage transmission and void its warranty.

Transmission Maintenance Schedule

•Check case housing for damage and possible fluid leakage after each use.

•Check transmission fluid level every 100 hours or ever 6 months of operation, whichever comes first.

•Change transmission fluid every 1000 hrs or immediately if water gets into it.

1.Prepare vehicle for maintenance as outlined in steps 1-6 on page 24.

2.Place a suitable container below housing to catch used oil. Remove dip stick and drain plug.

3.Allow used oil to drain completely and then reinstall drain plug and tighten securely with 5 to 15 in. lbs. of torque.

4.Dispose of used oil in a manner that is compatible with the environment. Do not throw used oil in the trash, pour it on the ground, or down a drain.

5.Fill transmission case with 2 quarts of Dextron 3 automatic transmission fluid at the dipstick port.Do not overfill. See "Section 10 Specifications and Capacities" on page 42.

6.Replace dipstick and check oil level.

Transmission Fluid Type and Capacity

See also "Section 10 Specifications and Capacities" on page 42.

•Type of Fluid: 5W30 Synthetic motor oil (S/N 460312+) Dextron 3 automatic transmission fluid (S/N 460311-)

•Fluid capacity: 2 quarts or fill to the full mark, “H” mark on the dipstick.

Transmission Oil Level Check

Refer to Figure 7-8

100 hrs / 6 mos.

Check transmission oil level at the dip stick as follows:

1.Prepare vehicle for maintenance as outlined in steps 1-6 on page 24.

2.Allow enough time for transmission oil to settle before checking oil level at the dipstick. Oil level may be checked cold or after several hours of operation.

3.Clean around the dipstick before removing it to keep dirt and debris out of the transmission.

4.Remove dipstick and wipe clean.

5.Fully insert dipstick and remove. Oil, hot or cold, should be at the “H” mark on the dipstick but not over.

6.If oil level on dipstick is low, fill at the dipstick opening with recommended oil. Repeat steps 3, 4, 5 and 6 until oil level on dipstick indicates full. Do not overfill.

Transmission Fluid Change

Refer to Figure 7-8and Figure 7-9

1000 hrs

Fill And

Oil Check

22083

Figure 7-8

Drain Plug

22082

Figure 7-9

36

4400EX Heavy Duty Off Road Utility Vehicle 720-132M

7/01/05

Page 37 Page 39
Image 38
Page 37 Page 39
Contents Gondo Table of Contents Application Safety FirstUsing This Manual IntroductionSerial Number Plate Land Pride Service Department East North StreetOwner Assistance Product SupportImportant Safety Information Safety SymbolBe Aware of Signal Words For Your ProtectionPrepare for Emergencies Practice Safe MaintenanceTire Safety Wear Protective EquipmentSafe Operating Procedures Table of Contents Safety Decals 818-543C838-492C 838-629C 838-486C 838-490C 838-628C 838-667C838-688C Machine RolloverPre-Delivery and Check List Dealer Service and Inspection ListPre-Delivery Certificate Vehicle InformationDealer Delivery To Customer List Customer Acceptance ListOperating Instructions Operator ResponsibilitiesGeneral Operation Foot Operated Controls Hand Operated Controls Engine Hood ReleaseSeat Belt Components Fuel IndicatorSteering Seat BeltsDriving Conditions Pulling Loads Towing the GondoTraverse Traveling on Steep Hills Towing Without a TrailerPlan Your Route Traveling Tips From the Trail MastersPreparation and Planning Plan Your GearTable of Contents Dump Bed Option Options and AccessoriesGondo Options Tailgate Operation Cargo box option onlyGondo Accessories Maintenance General MaintenancePrepare Vehicle for Maintenance Torque ValuesJacking the Vehicle Tire MaintenanceTire Inflation Chart Inflation PSI Front Tires Rear Tires Seat BeltsElectrical System BatteryJump Starting the Battery Prepare Vehicle to Jump-StartFuel System Disconnecting Jumper CablesConnecting Jumper Cables Emptying the Fuel Tank Fuel Filter and Fuel Line MaintenanceFilling the Fuel Tank General Information Engine MaintenancePower Steering Belt High Altitude Carburetor KitPrecleaner Foam Element Air Filter Maintenance ScheduleAir Filter Replacement Parts Engine Air FilterSpark Arrester Replacement Parts Spark Arrester Maintenance ScheduleSpark Arrester Maintenance Procedure Spark ArresterMaintenance Schedule Lubrication and Fluids Engine Oil Maintenance ScheduleEngine Oil Engine Oil Type and CapacityRefer to Figures 7-1, 7-2, 7-3, 7-4 Engine Oil and Filter ChangeLand Pride Oil Filter Differential Oil Level Check Differential Maintenance ScheduleDifferential Oil Type and Capacity Differential Oil ChangeTransmission Fluid Type and Capacity Transmission Maintenance ScheduleTransmission Fluid Transmission Oil Level CheckBrake Fluid Steering & Cargo Lift Cylinder FluidPillow Block Bearing Grease Type LubricationDriveline U-Joints Rotating Bearing SurfacesVehicle Storage Preparation Seasonal StorageEngine Preparation for Storage Vehicle Removal From Storage PreparationScratch IntroductionLight Scuff Body RepairDeep Gouge Specifications and Capacities 4400EX Series GondoTable of Contents Troubleshooting Engine overheats Engine runs unevenlyPark brake doesn’t work Engine stops runningGear Shift is malfunctioning Starter cranks slowlyVehicle speed does not reach 17 MPH Steering does not track correctlySteering play is excessive Vehicle looses ground speed withoutIn-tpi Ft-lb Torque Values ChartAppendix Land Pride Limited Warranty Utility VehicleCorporate Office P.O. Box 5060 Salina, Kansas 67402-5060 USA

22081, 22076, 720-132M specifications

Land Pride is renowned for its high-quality agricultural and landscaping equipment, and among its impressive lineup, the Land Pride 720-132M mower stands out as a versatile solution for various mowing applications. Designed with performance and efficiency in mind, the 720-132M mower is perfect for both residential and commercial users looking for a reliable machine capable of handling diverse terrain and mowing conditions.

One of the key features of the 720-132M is its robust cutting deck, which measures 132 inches in width. This wide cutting capability allows for expansive mowing coverage in fewer passes, significantly reducing mowing time and increasing productivity. The deck is constructed from heavy-duty materials, ensuring durability and longevity even when used in challenging environments.

Equipped with a high-performance cutting system, the mower boasts engineered blades that provide a clean and precise cut, promoting healthier lawn growth. The unique blade overlap design ensures consistent cutting performance across the entire width of the deck, reducing the likelihood of uncut areas left behind.

The Land Pride 720-132M features adjustable cutting height settings, giving operators the flexibility to adapt the mower to various grass types and desired finish quality. This adjustability is crucial for achieving optimal results, especially when transitioning from different mowing conditions.

Safety is a top priority for Land Pride, and the 720-132M integrates several safety features to protect both the operator and the equipment. Its robust frame design provides stability during operation, while operator presence controls ensure the mower stops when the operator leaves the seat, mitigating the risk of unintended accidents.

The mower is compatible with a wide range of tractors, allowing for seamless integration with existing equipment. Its simple attachment system enables quick mounting and dismounting, making it user-friendly and convenient for varying mowing tasks.

Another notable technology in the 720-132M is its efficient power transfer system. The mower is designed to maximize performance while minimizing wear and tear on the tractor, ensuring that operators can tackle their mowing tasks with confidence and ease.

Overall, the Land Pride 720-132M mower, with its advanced technologies and features, stands out as a leading choice for those seeking reliable and efficient mowing solutions tailored to both professional and personal landscaping needs.
Top Page Image Contents