Homelite HG1800 Starting the unit, Lubrication, Fuel, PRE-START Preparation, Starting the Engine

Page 9

LUBRICATION

Operating the unit without lubricant can damage the engine.

Fill the engine with lubricant according to the engine man- ual. For units with a dipstick, fill lubricant to the proper level. Units without a dipstick should be filled to the top of the opening of the lubricant fill.

FUEL

Fill the tank with clean, fresh unleaded automotive gasoline. Regular grade gasoline may be used provided a high octane rating is obtained (at least 85 pump octane). We recommend always using a fuel stabilizer. A fuel stabilizer will minimize the formulation of fuel gum deposits during storage. The fuel sta- bilizer can be added to the gasoline in the fuel tank, or into the gasoline in a storage container. Do not use E85 fuel.

caution:

Do not overfill the tank. Keep maximum fuel level 1/4 inch below the top of the fuel tank. This will allow expansion in hot weather and prevent overflow.

starting the unit

warning:

Gasoline is very dangerous. Serious injury or death can result from fire caused by gasoline contacting hot surfaces.

Do not fill fuel tank with engine running.

Do not spill fuel while refilling tank.

Do not mix oil with gasoline.

Follow all instructions and warnings in the engine manual.

PRE-START PREPARATION

Before starting the generator, check for loose or missing parts and for any damage which may have occurred during shipment.

warning:

This generator must not be operated without all factory installed heat shields in place. Failure to comply may cause the fuel tank to overheat and result in personal injury from fire.

STARTING THE ENGINE

Check lubricant level and fuel.

Disconnect all electrical loads from the unit.

Open fuel shut off valve.

Adjust choke as necessary.

Set the engine switch to the “ON” position.

Pull on the starter rope with fast steady pull. As the engine warms up, readjust the choke.

danger:

Provide adequate ventilation for toxic exhaust gases and cooling air flow.

Do not start or run the generator in an enclosed area, even if door or windows are open.

Engines give off carbon monoxide, an odorless, colorless, poison gas.

Breathing carbon monoxide can cause nausea, fainting or death.

caution:

Allow generator to run at no load for five minutes upon each initial start-up to permit engine and generator to stabilize.



Page 8 Page 10
Image 9
Page 8 Page 10
Contents Manuel de l’opérateur Manual del operador Groupe electrogene Generador electricoSérie HG1800 Serie HG1800 Table of contents / TABLE DES MATIERES / INDICE Safety and Operation Rules Safety informationOperating voltage Spark ARRESTing mufflerDetermining total wattage KW = 1,000 wattsElectrical Power ManagementExtension cord cable size Control panel Major generator featuresGrounding the Generator Installation Before OperationGround Terminal Location Ground lugLubrication Starting the unitFuel PRE-START PreparationMaintenance Engine maintenance schedule Fuel tank venting Service and storageInfrequent Service Spark arrester mufflerLimited warranty Service informationHOW to Order Replacement Parts Warranty Periods Limited 3-year engine warrantyAvertissement Règles D’OPÉRATION ET DE SécuritéVérifier LA Tension PARE-ÉTINCELLESDétermination DE LA Puissance Totale Nécessaire 1KW = 1 000 wattsCaractéristiques électriques 120 240 Calibre Taille du câble du cordon prolongateurCaractéristiques Principales DU Groupe Electrogene Tableau DE CommandePrise double de 120 V, 15 a Disjoncteurs’EMPLACEMENT DE Borne DE MIS À Terre InstallationAvant DE Mettre EN Marche Mise EN Place DE L’APPAREILLubrification Demarrage DE L’APPAREILCarburant Préparatifs AU DémarrageEntretien LE Silencieux PARE-ETINCELLES Donner Vent DE Reservoir DE CarburantUsage ET Entreposage LE Plan D’ENTRETIEN DE MoteurService Clientele Commande DE Pièces DE RechangeGarantie Limitée Garantie Limitée DE Trois ANS SUR LE Moteur Garantie limitée de Subaru RobinPériodes DE Garantie Peligro Reglas DE Seguridad Y DE FuncionamientoAdvertencia PrecauciónApagachispas EL Requerimiento DE VoltajeComo Determinar EL Vataje Total 1KW = 1,000 wattsAspectos eléctricos Cargas de motores eléctricos Panel de control Caracteristicas Principales DEL GeneradorAdvertenica Receptáculo dúplex de 120 voltios, 15 amperesAntes DE LA Operacion InstalacionPuesta a Tierra DEL Generador LA Ubicacion DE Terminal DEL TierraLubricacion Arranque DEL UnidadCombustible Preparacion Antes DE ArrancarMantenimiento EL Horario DE LA Mantenimientodel Motor Tanque DEL Combustible DescargarServicio Poco Frecuente Almacenamiento a Largo PlazoGarantia Limitada Servicio AL ClienteComo Pedir LOS Repuestos Períodos DE Garantía Motor CON Garantía Limitada DE 3 AñosParts Drawing / Schema DES Pièces / Diagrama DE Piezas Part Description Descripción QTY Parts List / Liste DES Pièces / Lista DE PiezasAvertissement Page NE PAS Retourner AU Magasin ¡PRIMERO Llámenos

HG1800 specifications

The Homelite HG1800 is a powerful and versatile generator designed for both residential and light commercial use. Known for its reliability and efficiency, this generator is particularly popular among homeowners looking for a dependable backup power source during outages and those who need portable electricity for outdoor activities.

One of the standout features of the Homelite HG1800 is its robust 1800-watt output, which allows it to power multiple appliances simultaneously. With a peak output of 2300 watts, the generator can easily start larger devices such as refrigerators, power tools, and air conditioners. This makes it an ideal choice for emergency power needs as well as recreational purposes, such as camping or tailgating.

The generator is equipped with a 4-stroke, air-cooled engine, designed for efficient fuel consumption and longer operating times. It has a runtime of up to 9 hours at a 50% load, ensuring that users can rely on it throughout the day and into the night without frequent refueling. The engine is designed to meet stringent emissions standards, making it an environmentally friendly choice for those conscious about their carbon footprint.

Portability is another key characteristic of the Homelite HG1800. Weighing only around 50 pounds, it features a compact design with built-in handles, allowing for easy transport from one location to another. Whether you’re powering a construction site or enjoying a weekend getaway, this generator can be easily loaded into a vehicle or moved around your yard.

The generator also embraces user-friendly technologies. It features a simple recoil start mechanism that ensures quick and reliable starting, even for those who may not have extensive experience with generators. Additionally, the Homelite HG1800 includes multiple outlets, including two 120-volt AC outlets and one 12-volt DC outlet, providing versatility in what devices can be powered.

Safety features of the HG1800 generator include overload protection, which automatically shuts off the unit if it is overloaded, protecting both the generator and the connected devices. It also has a low oil shutdown feature, which halts operation when oil levels are too low, preventing engine damage.

In summary, the Homelite HG1800 generator is an excellent choice for those in need of a reliable, portable, and efficient power solution. With its solid wattage output, user-friendly design, and essential safety features, the HG1800 stands out as a practical and valuable addition to anyone’s power supply options, catering to both emergency and recreational power needs.
Top Page Image Contents