Replacement Parts, Service Hints, Technical Service | Desa CDCFPRA

REPLACEMENT PARTS

REPLACEMENT PARTS

Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty.

PARTS UNDER WARRANTY

Contact authorized dealers of this product. If they canʼt supply original replacement part(s), call DESA Heating Productsʼ Technical Service Department at 1-866-672-6040.

When calling DESA Heating Products, have ready

•your name

•your address

•model and serial numbers of your ﬁreplace

•how ﬁreplace was malfunctioning

•type of gas used (propane/LP or natural gas)

•purchase date

Usually, we will ask you to return the part to the factory.

PARTS NOT UNDER WARRANTY

Contact authorized dealers of this product. If they canʼt supply original replacement part(s), call DESA Heating Products at 1-866-672-6040 for referral information.

When calling DESA Heating Products, have ready

•model number of your ﬁreplace

•the replacement part number

SERVICE HINTS

When Gas Pressure Is Too Low

•pilot will not stay lit

•burners will have delayed ignition

•ﬁreplace will not produce speciﬁed heat

•for propane/LP units, propane/LP gas supply may be low

You may feel your gas pressure is too low. If so, con- tact your local natural or propane/LP gas supplier.

TECHNICAL SERVICE

You may have further questions about installation, operation, or troubleshooting. If so, contact DESA Heating ProductsʼTechnical Service Department at 1-866-672-6040. When calling, please have your model and serial numbers of your heater ready.

You can also visit DESA Heating Productsʼtechni- cal services web site at www.desatech.com.

116658-01A

www.desatech.com

33

Image 33

Desa CDCFPRA, CDCFNRA Replacement Parts, Service Hints, Technical Service, Parts Under Warranty, Parts Not Under Warranty

Contents

WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance 116658-01A TABLE OF CONTENTS SAFETY INFORMATION DANGER Carbon monoxide poisoning may lead to deathWARNING Any change to this ﬁreplace or its controls can be dangerous See Accessories, page CONTROL ACCESSORIESOPTIONAL REMOTE Continued SAFETY PILOT diagrams or failure to use onlyWARNING Always have ﬁreplace. This prevents exces PROVIDING ADEQUATE VENTILATION b. weather stripping has been added on openable windows and doors andFigure 3 - Assembling Hood Unusually Tight Construction DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATION Conﬁned and Unconﬁned SpaceDetermining if You Have a Conﬁned or Unconﬁned Space in a recreational vehicle WARNING Never install the ﬁreplace in a bedroom or bathroomas a ﬁreplace insert in high trafﬁc areas in windy or drafty areas VENTILATION AIR Before installing ﬁreplace, make sure you have the items listed below INSTALLATION ITEMSexternal regulator supplied by installer, for propane/LP units only CHECK GAS TYPE locate ﬁreplace where moving vehicle will not hit it CAUTION If you install the ﬁreplace in a home garageBUILT-IN FIREPLACE INSTALLATION Figure 7 - Rough Opening for Installing in Wall 4. If you have not installed hood, follow instruc- tions on page Note A qualiﬁed installer should make all electri- cal connections7. Bend four nailing ﬂanges on outer casing with pliers see Figure Figure 9 - Attaching Fireplace to Wall Studs OPTIONAL MANTEL INSTALLATION of the following raise the mantel to an accept- able heightremove the mantel INSTALLING OPTIONAL BLOWER ACCESSORY GA3450TA Figure 12 - Attaching Brass Trim to FireplaceFigure 13 - Assembling Brass Trim Installing Blower Accessory Screw Figure 16 - Installing Switch Plate to Remote/Blower BracketCAUTION Verify proper op- eration after servicing For Built-In Installation Figure 17 - Installing Blower Bracket AssemblyFigure 18 - Wiring Diagram For Blower Accessory Built-In Installation CONNECTING TO GAS SUPPLY WARNING Test all gas piping installing or servicing. Correctand connections, internal and external to unit, for leaks after PRESSURE TESTING FIREPLACE GAS CONNECTIONS PRESSURE TESTING GAS SUPPLY PIPING SYSTEMFigure 24 - Checking Gas Joints Propane/LP Only Figure 25 - Checking Gas Joints Natural Gas Only Figure 26 - Disconnecting Wires From Control Valve OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIESFigure 28 - Installing Remote Receiver OPTIONAL WALL MOUNTED THERMOSTAT - GWMT1 Figure 30 - Connecting Wire Terminals 7. Install the base onto the wall with the provided screws“W” and “R” OPTIONAL WALL SWITCH - GWMS2 1. Remove jumper wire from control valve see Figure 26, page Figure 35 - Installing Log Figure 33 - Installing Rear Brick LinerFigure 36 - Installing Screen Figure 34 - Installing Side Brick Liners FOR YOUR SAFETY READ BEFORE LIGHTING OPERATING FIREPLACELIGHTING INSTRUCTIONS 2. If Using Optional Hand-Held Remote MANUAL LIGHTING PROCEDURETO TURN OFF GAS TO APPLIANCE OPTIONAL HAND-HELD REMOTE OPERATION Control Knob and Flame Adjustment Knob for Remote Operation Figure 40 - Setting the Selector Switch3. Press the POWER and LOCK buttons together to turn off the ﬁreplace 4. Press the POWER and LOCK buttons together to turn off the ﬁreplace see Troubleshooting, page OPTIONAL GWMS2 WALL MOUNTED SWITCHOPTIONAL GWMT1 WALL MOUNTED THERMOSTAT PILOT FLAME PATTERN CONTINUED WARNING Turn off ﬁreplace and let cool before cleaningBURNER FLAME PATTERN BURNER INJECTOR HOLDER AND PILOT AIR INLET HOLE CABINET LOG SETFigure 48 - Pilot Inlet Air Hole Propane/LP Gas Figure 49 - Pilot Inlet Air Hole Natural Gas OBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDY OBSERVED PROBLEM POSSIBLE CAUSE see Cleaning and Mainte WARNING If you smell gas Shut off gas supply Do not try to light any applianceIf you cannot reach your gas supplier, call the ﬁre department Remote-Ready Models SPECIFICATIONSCDCFPRA CDCFNRA SERVICE HINTS REPLACEMENT PARTSTECHNICAL SERVICE PARTS UNDER WARRANTY BREAKDOWN PARTSILLUSTRATED MODELS FIREBOX CDCFNRA FIREBOX MODELS CDCFNRA, CDCFPRA PARTS LIST ILLUSTRATED PARTS BREAKDOWN NaturalGas Only REMOTE-READY MODELS THERMOSTAT-CONTROLLED BLOWER KIT GA3450TA NOTICE All accessories may not be available for all ﬁreplace modelsEQUIPMENT SHUTOFF VALVE GA5010 BRASS TRIM KIT - GA6095 WALL-MOUNT THERMOSTAT SWITCH GWMT1 CLEANING KIT - GCK/CCKWALL-MOUNT ON/OFF SWITCH GWMS2 RECEIVER AND HAND-HELD REMOTE CONTROL KIT - HRC100 AND HRC1011 2701 Industrial Drive P.O. Box NOT A UPC 116658-01 Rev. A 04/05116658