WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance
TABLE OF CONTENTS
116658-01A
WARNING Any change to this fireplace or its controls can be dangerous
SAFETY INFORMATION
DANGER Carbon monoxide poisoning may lead to death
CONTROL ACCESSORIES
See Accessories, page
OPTIONAL REMOTE
Continued
sive temperatures on fireplace
diagrams or failure to use only
SAFETY PILOT
WARNING Always have
b. weather stripping has been added on openable windows and doors and
Continued
PROVIDING ADEQUATE VENTILATION
Figure 3 - Assembling Hood
Continued
DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATION
Confined and Unconfined Space
Determining if You Have a Confined or Unconfined Space
WARNING Never install the fireplace in a bedroom or bathroom
in a recreational vehicle
as a fireplace insert in high traffic areas in windy or drafty areas
Continued
INSTALLATION ITEMS
Before installing fireplace, make sure you have the items listed below
external regulator supplied by installer, for propane/LP units only
CHECK GAS TYPE
CAUTION If you install the fireplace in a home garage
locate fireplace where moving vehicle will not hit it
BUILT-IN FIREPLACE INSTALLATION
Figure 7 - Rough Opening for Installing in Wall
Note A qualified installer should make all electri- cal connections
4. If you have not installed hood, follow instruc- tions on page
7. Bend four nailing flanges on outer casing with pliers see Figure
Figure 9 - Attaching Fireplace to Wall Studs
OPTIONAL MANTEL INSTALLATION
of the following raise the mantel to an accept- able height
remove the mantel
Continued
INSTALLING OPTIONAL BLOWER ACCESSORY GA3450TA
Continued
Figure 12 - Attaching Brass Trim to Fireplace
Figure 13 - Assembling Brass Trim
Installing Blower Accessory
Screw Figure 16 - Installing Switch Plate to Remote/Blower Bracket
CAUTION Verify proper op- eration after servicing
Continued
For Built-In Installation
Figure 17 - Installing Blower Bracket Assembly
Figure 18 - Wiring Diagram For Blower Accessory Built-In Installation
Continued
CONNECTING TO GAS SUPPLY
Continued
installing or servicing. Correct
WARNING Test all gas piping
and connections, internal and
external to unit, for leaks after
PRESSURE TESTING GAS SUPPLY PIPING SYSTEM
PRESSURE TESTING FIREPLACE GAS CONNECTIONS
Continued
Figure 24 - Checking Gas Joints Propane/LP Only
OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIES
Figure 26 - Disconnecting Wires From Control Valve
Figure 28 - Installing Remote Receiver
Continued
7. Install the base onto the wall with the provided screws
Figure 30 - Connecting Wire Terminals
“W” and “R” OPTIONAL WALL SWITCH - GWMS2
1. Remove jumper wire from control valve see Figure 26, page
Figure 33 - Installing Rear Brick Liner
Figure 35 - Installing Log
Figure 36 - Installing Screen
Figure 34 - Installing Side Brick Liners
LIGHTING INSTRUCTIONS
FOR YOUR SAFETY READ BEFORE LIGHTING
OPERATING FIREPLACE
MANUAL LIGHTING PROCEDURE
2. If Using Optional Hand-Held Remote
TO TURN OFF GAS TO APPLIANCE
OPTIONAL HAND-HELD REMOTE OPERATION
Figure 40 - Setting the Selector Switch
Control Knob and Flame Adjustment Knob for Remote Operation
3. Press the POWER and LOCK buttons together to turn off the fireplace
4. Press the POWER and LOCK buttons together to turn off the fireplace
OPTIONAL GWMS2 WALL MOUNTED SWITCH
see Troubleshooting, page
Continued
OPTIONAL GWMT1 WALL MOUNTED THERMOSTAT
WARNING Turn off fireplace and let cool before cleaning
see Troubleshooting, page
CONTINUED
BURNER FLAME PATTERN
Continued
LOG SET
CABINET
Figure 48 - Pilot Inlet Air Hole Propane/LP Gas
TROUBLESHOOTING
OBSERVED PROBLEM
POSSIBLE CAUSE
REMEDY
TROUBLESHOOTING
OBSERVED PROBLEM POSSIBLE CAUSE
Continued
REMEDY
OBSERVED PROBLEM
see Cleaning and Mainte
Continued
POSSIBLE CAUSE
OBSERVED PROBLEM POSSIBLE CAUSE
WARNING If you smell gas Shut off gas supply
Do not try to light any appliance
If you cannot reach your gas supplier, call the fire department
SPECIFICATIONS
Remote-Ready Models
CDCFPRA
CDCFNRA
REPLACEMENT PARTS
SERVICE HINTS
TECHNICAL SERVICE
PARTS UNDER WARRANTY
PARTS
BREAKDOWN
ILLUSTRATED MODELS
116658-01A
PARTS LIST
FIREBOX MODELS CDCFNRA, CDCFPRA
ILLUSTRATED PARTS BREAKDOWN
REMOTE-READY MODELS CDCFNRA AND CDCFPRA
Natural
Gas Only
PARTS LIST
REMOTE-READY MODELS
NOTICE All accessories may not be available for all fireplace models
THERMOSTAT-CONTROLLED BLOWER KIT GA3450TA
EQUIPMENT SHUTOFF VALVE GA5010
BRASS TRIM KIT - GA6095
CLEANING KIT - GCK/CCK
WALL-MOUNT THERMOSTAT SWITCH GWMT1
WALL-MOUNT ON/OFF SWITCH GWMS2
RECEIVER AND HAND-HELD REMOTE CONTROL KIT - HRC100 AND HRC1011
116658
2701 Industrial Drive P.O. Box
NOT A UPC 116658-01 Rev. A 04/05
