Parts, Breakdown, Illustrated Models, 116658-01A

16	FIREBOX CDCFNRA,

www.desatech.com

116658-01A

20	22

	10
	16
	6
		16
10
8	14	10
10		10
10		14
		14

17 16

9 12

11 7

14		ILLUSTRATED MODELS
16
	16
	CDCFPRA
	16	PARTS
	14	PARTS
	14	BREAKDOWN
	16
	14

Page 34

Image 34

Desa CDCFNRA, CDCFPRA installation manual Parts, Breakdown, Illustrated Models, 116658-01A, Firebox Cdcfnra, Cdcfpra

Contents

WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance TABLE OF CONTENTS 116658-01A DANGER Carbon monoxide poisoning may lead to death SAFETY INFORMATIONWARNING Any change to this ﬁreplace or its controls can be dangerous OPTIONAL REMOTE CONTROL ACCESSORIESSee Accessories, page Continued WARNING Always have diagrams or failure to use onlySAFETY PILOT ﬁreplace. This prevents exces Figure 3 - Assembling Hood b. weather stripping has been added on openable windows and doors andPROVIDING ADEQUATE VENTILATION Unusually Tight Construction Conﬁned and Unconﬁned Space DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATIONDetermining if You Have a Conﬁned or Unconﬁned Space as a ﬁreplace insert in high trafﬁc areas in windy or drafty areas WARNING Never install the ﬁreplace in a bedroom or bathroomin a recreational vehicle VENTILATION AIR external regulator supplied by installer, for propane/LP units only INSTALLATION ITEMSBefore installing ﬁreplace, make sure you have the items listed below CHECK GAS TYPE BUILT-IN FIREPLACE INSTALLATION CAUTION If you install the ﬁreplace in a home garagelocate ﬁreplace where moving vehicle will not hit it Figure 7 - Rough Opening for Installing in Wall 7. Bend four nailing ﬂanges on outer casing with pliers see Figure Note A qualiﬁed installer should make all electri- cal connections4. If you have not installed hood, follow instruc- tions on page Figure 9 - Attaching Fireplace to Wall Studs of the following raise the mantel to an accept- able height OPTIONAL MANTEL INSTALLATIONremove the mantel Figure 12 - Attaching Brass Trim to Fireplace INSTALLING OPTIONAL BLOWER ACCESSORY GA3450TAFigure 13 - Assembling Brass Trim Screw Figure 16 - Installing Switch Plate to Remote/Blower Bracket Installing Blower AccessoryCAUTION Verify proper op- eration after servicing Figure 17 - Installing Blower Bracket Assembly For Built-In InstallationFigure 18 - Wiring Diagram For Blower Accessory Built-In Installation CONNECTING TO GAS SUPPLY and connections, internal and installing or servicing. CorrectWARNING Test all gas piping external to unit, for leaks after Figure 24 - Checking Gas Joints Propane/LP Only PRESSURE TESTING GAS SUPPLY PIPING SYSTEMPRESSURE TESTING FIREPLACE GAS CONNECTIONS Figure 25 - Checking Gas Joints Natural Gas Only Figure 28 - Installing Remote Receiver OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL ACCESSORIESFigure 26 - Disconnecting Wires From Control Valve OPTIONAL WALL MOUNTED THERMOSTAT - GWMT1 “W” and “R” OPTIONAL WALL SWITCH - GWMS2 7. Install the base onto the wall with the provided screwsFigure 30 - Connecting Wire Terminals 1. Remove jumper wire from control valve see Figure 26, page Figure 36 - Installing Screen Figure 33 - Installing Rear Brick LinerFigure 35 - Installing Log Figure 34 - Installing Side Brick Liners OPERATING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTINGLIGHTING INSTRUCTIONS TO TURN OFF GAS TO APPLIANCE MANUAL LIGHTING PROCEDURE2. If Using Optional Hand-Held Remote OPTIONAL HAND-HELD REMOTE OPERATION 3. Press the POWER and LOCK buttons together to turn off the ﬁreplace Figure 40 - Setting the Selector SwitchControl Knob and Flame Adjustment Knob for Remote Operation 4. Press the POWER and LOCK buttons together to turn off the ﬁreplace OPTIONAL GWMT1 WALL MOUNTED THERMOSTAT OPTIONAL GWMS2 WALL MOUNTED SWITCHsee Troubleshooting, page PILOT FLAME PATTERN BURNER FLAME PATTERN WARNING Turn off ﬁreplace and let cool before cleaningCONTINUED BURNER INJECTOR HOLDER AND PILOT AIR INLET HOLE Figure 48 - Pilot Inlet Air Hole Propane/LP Gas LOG SETCABINET Figure 49 - Pilot Inlet Air Hole Natural Gas POSSIBLE CAUSE TROUBLESHOOTINGOBSERVED PROBLEM REMEDY OBSERVED PROBLEM POSSIBLE CAUSE see Cleaning and Mainte Do not try to light any appliance WARNING If you smell gas Shut off gas supplyIf you cannot reach your gas supplier, call the ﬁre department CDCFPRA SPECIFICATIONSRemote-Ready Models CDCFNRA TECHNICAL SERVICE REPLACEMENT PARTSSERVICE HINTS PARTS UNDER WARRANTY ILLUSTRATED MODELS PARTSBREAKDOWN FIREBOX CDCFNRA PARTS LIST FIREBOX MODELS CDCFNRA, CDCFPRA Natural ILLUSTRATED PARTS BREAKDOWNGas Only REMOTE-READY MODELS EQUIPMENT SHUTOFF VALVE GA5010 NOTICE All accessories may not be available for all ﬁreplace modelsTHERMOSTAT-CONTROLLED BLOWER KIT GA3450TA BRASS TRIM KIT - GA6095 WALL-MOUNT ON/OFF SWITCH GWMS2 CLEANING KIT - GCK/CCKWALL-MOUNT THERMOSTAT SWITCH GWMT1 RECEIVER AND HAND-HELD REMOTE CONTROL KIT - HRC100 AND HRC1011 NOT A UPC 116658-01 Rev. A 04/05 2701 Industrial Drive P.O. Box116658

Desa CDCFNRA, CDCFPRA Parts, Breakdown, Illustrated Models, 116658-01A, Firebox Cdcfnra, Cdcfpra

Models: CDCFPRA CDCFNRA

FIREBOX CDCFNRA,

ILLUSTRATED MODELS

CDCFPRA

PARTS

BREAKDOWN