Safety, 107-2102, 109-6014 | Exmark 4500-996 Rev A specification

Safety

107-2102

109-3148

109-6014

116-1119

116-1496

116-3303

Page 12

Image 12

Exmark 4500-996 Rev A manual Safety, 107-2102, 109-6014

Contents

PIONEER E-SERIES For Serial Nos 312,000,000 & Higher CALIFORNIA Proposition 65 Warning All Rights Reserved Introduction Model No Serial No Contents Safety Safety Alert SymbolSafety ALERT! YOUR SAFETY IS INVOLVED DANGER Avoid prolonged breathing of vaporsKeep face away from nozzle and gas tank/container opening Keep away from eyes and skin Never siphon by mouth Operation Slope OperationAllow engine parts, especially the muffler, to cool before touching Remove accumulated debris from muffler and engine area Using the Rollover Protection System ROPS Maintenance and StorageDo Not mow slopes when grass is wet Lower the roll bar only when absolutely necessary Keep sparks, flames, or cigarettes away from battery Ventilate when charging or using battery in an enclosed spaceDo Not swallow electrolyte Use cardboard or paper, not your hands, to find hydraulic leaks Safety and Instructional Decals 107-2102 109-6014 PTO Switch Symbols 116-6363116-4308 116-4465 109-6016 116-4430Reverse Specifications SpecificationsSafety Interlock System Model Numbers Tires & Wheels SeatHydrostatic Ground Drive System Cutting Deck Dimensions Curb WeightTorque Requirements Overall Width Product Overview ControlsOperation Motion Control Levers Ignition Switch Throttle ControlBrake Lever Hour Meter PTO Engagement Switch Drive Wheel Release ValvesDo Not tow machine Pre-Start Operating InstructionsDeck Lift Pedal Transport Lock Open the Fuel Shut-Off Valve Starting the EngineEngaging the PTO Use caution when making turns Disengaging the PTOStopping the Engine Driving the Machine Adjusting the Cutting Height Driving in Reverse Adjusting the Anti-Scalp Rollers TransportingTransporting a Unit Do Not drive a unit on a public street or roadway Use extreme caution when operating a unit on a ramp Loading a Unit Maintenance Recommended Maintenance SchedulesMaintenance Periodic Maintenance Check Battery ChargeRecommended Jump Starting Procedure Service Interval Before each use or daily Do Not jump start a weak battery if these conditions exist Check Mower BladesBatteries contain acid and produce explosive gases Shield the eyes and face from the batteries at all times Check Safety Interlock System SERVICE DEALER4. Blade bolt washer assembly - Torque to 50-60 ft-lb 1. Spindle 2. Blade 3. Blade drive washer Service Air Cleaner Service Interval After the first 5 hoursCheck Rollover Protections Systems Roll Bar Knobs Check Seat Belt Service Interval Every 50 hours Note See chart for service intervalsService Interval Every 200 hours Check Tire Pressures Service Interval Every 500 hours Service Interval After the first 100 hoursReplace Emissions Air Intake Filter Change Hydraulic System Filter and Fluid Do Not refuel or run engine unless spark arrester is installed Check Spark Arrester if equippedThread Locking Adhesives Copper-Based Anti-seize Adjustments Adjusting the Blade SlopeDeck Leveling Blade Slope Adjusting the Parking Brake Pump Drive Belt TensionDeck Belt Tension Motion Control Handle Adjustment Adjusting the heightAdjusting the Tilt Full Forward Tracking Adjustment Motion Control Linkage Adjustment Adjusting the Seat Ride Suspension Electric Clutch AdjustmentNo adjustment necessary 8. Tighten nuts Cleaning Clean Engine and Exhaust System AreaRemove Engine Shrouds and Clean Cooling Fins Clean Hydro Fan Cooling Fins Battery Disposal recycling center or according to your state and local regulations Troubleshooting Troubleshooting see Drive Wheel Release Valves section Cutting blades is/are bent or unbalanced Schematics SchematicsElectrical Diagram Electrical Logic Schematic Pioneer E-Series Turf Equipment 1 Year Limited Commercial Warranty4 Year or 500 Hours Limited Consumer Warranty General Warranty Conditions and Products CoveredPage Page Service Record Service Done ByDate Description of Work DonePage This page may be copied for personal use SEE EXMARK’S COMPLETE LINE OF ACCESSORIES AND OPTIONS MID-MOUNT RIDING ACCESSORIES AND OPTIONSOUT-FRONT RIDING ACCESSORIES AND OPTIONS WALK-BEHIND ACCESSORIES AND OPTIONS