Schematics, Electrical Diagram | Exmark 4500-996 Rev A guide

Schematics

Schematics

Schematics

Electrical Diagram

44

Image 44

Exmark 4500-996 Rev A manual Schematics, Electrical Diagram

Contents

PIONEER E-SERIES For Serial Nos 312,000,000 & Higher CALIFORNIA Proposition 65 Warning All Rights Reserved Introduction Model No Serial No Contents Safety Safety Alert SymbolSafety ALERT! YOUR SAFETY IS INVOLVED DANGER Avoid prolonged breathing of vaporsKeep face away from nozzle and gas tank/container opening Keep away from eyes and skin Never siphon by mouth Operation Slope OperationAllow engine parts, especially the muffler, to cool before touching Remove accumulated debris from muffler and engine area Using the Rollover Protection System ROPS Maintenance and StorageDo Not mow slopes when grass is wet Lower the roll bar only when absolutely necessary Do Not swallow electrolyte Keep sparks, flames, or cigarettes away from batteryVentilate when charging or using battery in an enclosed space Use cardboard or paper, not your hands, to find hydraulic leaks Safety and Instructional Decals 107-2102 109-6014 PTO Switch Symbols 116-6363116-4308 116-4465 Reverse 109-6016116-4430 Specifications SpecificationsSafety Interlock System Model Numbers Tires & Wheels SeatHydrostatic Ground Drive System Cutting Deck Dimensions Curb WeightTorque Requirements Overall Width Product Overview ControlsOperation Motion Control Levers Ignition Switch Throttle ControlBrake Lever Hour Meter Do Not tow machine PTO Engagement SwitchDrive Wheel Release Valves Pre-Start Operating InstructionsDeck Lift Pedal Transport Lock Engaging the PTO Open the Fuel Shut-Off ValveStarting the Engine Use caution when making turns Disengaging the PTOStopping the Engine Driving the Machine Adjusting the Cutting Height Driving in Reverse Adjusting the Anti-Scalp Rollers TransportingTransporting a Unit Do Not drive a unit on a public street or roadway Use extreme caution when operating a unit on a ramp Loading a Unit Maintenance MaintenanceRecommended Maintenance Schedules Periodic Maintenance Check Battery ChargeRecommended Jump Starting Procedure Service Interval Before each use or daily Do Not jump start a weak battery if these conditions exist Check Mower BladesBatteries contain acid and produce explosive gases Shield the eyes and face from the batteries at all times Check Safety Interlock System SERVICE DEALER4. Blade bolt washer assembly - Torque to 50-60 ft-lb 1. Spindle 2. Blade 3. Blade drive washer Service Air Cleaner Service Interval After the first 5 hoursCheck Rollover Protections Systems Roll Bar Knobs Check Seat Belt Service Interval Every 50 hours Note See chart for service intervalsService Interval Every 200 hours Check Tire Pressures Service Interval Every 500 hours Service Interval After the first 100 hoursReplace Emissions Air Intake Filter Change Hydraulic System Filter and Fluid Do Not refuel or run engine unless spark arrester is installed Check Spark Arrester if equippedThread Locking Adhesives Copper-Based Anti-seize Adjustments Adjusting the Blade SlopeDeck Leveling Blade Slope Deck Belt Tension Adjusting the Parking BrakePump Drive Belt Tension Adjusting the Tilt Motion Control Handle AdjustmentAdjusting the height Full Forward Tracking Adjustment Motion Control Linkage Adjustment Adjusting the Seat Ride Suspension Electric Clutch AdjustmentNo adjustment necessary 8. Tighten nuts Cleaning Clean Engine and Exhaust System AreaRemove Engine Shrouds and Clean Cooling Fins Clean Hydro Fan Cooling Fins Battery Disposal recycling center or according to your state and local regulations Troubleshooting Troubleshooting see Drive Wheel Release Valves section Cutting blades is/are bent or unbalanced Electrical Diagram SchematicsSchematics Electrical Logic Schematic Pioneer E-Series Turf Equipment 1 Year Limited Commercial Warranty4 Year or 500 Hours Limited Consumer Warranty General Warranty Conditions and Products CoveredPage Page Service Record Service Done ByDate Description of Work DonePage This page may be copied for personal use SEE EXMARK’S COMPLETE LINE OF ACCESSORIES AND OPTIONS MID-MOUNT RIDING ACCESSORIES AND OPTIONSOUT-FRONT RIDING ACCESSORIES AND OPTIONS WALK-BEHIND ACCESSORIES AND OPTIONS