Temperature Control, Wheel Kit | Graco A-25 manual

Temperature Control

151		152
		152	155
			155
		154
			To B Heater
			Module
		153	To A Heater
			Module
			To Hose
			Heater
			Module
154
Ref. Part		Description	Qty.
151	16G925	PANEL, pod, mounting	1
152	247827	MODULE, heater control	1
153	247828	MODULE, heater	3
154	114183	NUT, hex, flanged, serrated	4
155	247801	CABLE, communication	1

Parts

Wheel Kit, 262695

195

193			194
			194
194		192
194
		191
		193
		ti18006a
Ref.	Part	Description	Qty.
191†	16H182	AXLE, wheel	2
192†	111841	WASHER, plain 5/8	4
193†	191824	WASHER, space	4
194†	101242	RING, retaining, ext.	4
195†	16G920	WHEEL, semi pneumatic, offset	2

†Only used with 262614. Available as add on wheel kit 262695.

3A1570A

45

Image 45

Graco A-25 important safety instructions Temperature Control, Wheel Kit, Ref. Part Description Qty

Contents

Repair-Parts Important Safety Instructions Contents Systems Proportioner ModelsRelated Manuals Manual Description Electric Shock Hazard Fire and Explosion Hazard Equipment Misuse Hazard Important Two-Component Material Information Changing Materials DataTrak Diagnostic Codes Temperature Control Diagnostic CodesSymbol Code Code Name Diagnosis Cause Causes of E01 Errors E01 High fluid temperatureSensor Connector Continuity Checks Pins Description Reading Checks E03 No zone current E02 High zone current E05 Control board over temperature E06 Communication cable unpluggedE99 Loss of communication Before Beginning Repair Pressure Relief ProcedureShutdown Open Close ParkFlushing Problems TroubleshootingPower Pumps and Pressures Problem Cause Solution Electronics Problem Cause Solution Problem Cause Solution See E04 Fluid Temperature Sen HeaterSor FTS or thermocouple discon Hose Heat System Problem Cause Solution Follow Pressure Relief Procedure, RepairDisconnect Pump Connect Pump Remove Air Motor Install Air Motor Recirculation / Over Pressure Relief Block Air Filter Element InstallationAir Inlet Filter / Water Separator Auto Drain Air Filter Element Removal Temperature Control Module Connections Temperature Control ModuleConnector Description Bottom of Power Modules Test SCR Circuit Replacing Temperature Control Assembly Modules Primary Heater Heater ElementLine Voltage KW Dual Zone Heater Thermocouple Thermocouple Check Hose Connectors Overtemperature SwitchPins Result Heated Hose Fluid Temperature Sensor FTS InstallationTest/Removal Transformer Primary Check Transformer Secondary Check Replace TransformerModel Secondary Voltage Size Component Replace Circuit Breaker Module Pump Lubrication System Pump Lubrication System Temperature Display Refer to Reactor A-25 Wiring Schematic,Fluid Inlet Strainer Screen Display Module Detail of Membrane Switches and Temperature Display Board Replace DataTrak Battery or Fuse Replace BatteryReplace Fuse Recommended Spare Parts Accessories 7984 100 888 Parts Torque pump locking nuts to 66-74 ft-lbs 90-100 Nm Cart Part Description Qty Nipple Screw Control Panel Temperature Control Wheel KitRef. Part Description Qty Fluid Inlet Kit Fluid Manifold Ring Kw Dual Zone Heater, 24J788 PLUG, Pipe Air Motor Pump Assembly Air Tubing Connections Length Connection Outside Ft m FromColor Diameter Breaker Module Phase Reactor A-25 Wiring Schematic POD Reactor A-25 Wiring Schematic Simplified Schematic, Heater Controls Category Data Technical Data Graco Information Graco Standard Warranty