Incorrect Positions | Hearth and Home Technologies 31M-ACC-MBK

R

3100 Wood Stove Series (ACC)

H. Correct Baffle & Blanket Placement

INCORRECT POSITIONS

WARNING

Fire Risk

Firebox damage due to improper baffle place-

ment is not covered by warranty. Operate the wood burning appliance with the baffle in the correct position only.

Not doing so could result in:

•Reduced efficiency

•Overheating the chimney

•Overheating the rear of the firebox

•Poor performance

Ensure correct baffle placement and replace baffle com- ponents if damaged or missing.

CORRECT POSITION

Ceramic Blanket and Baffle Board are NOT in contact with the back of the firebox.

Ceramic Blanket

Back of Firebox

Ceramic Blanket is NOT in contact with the back of the firebox and NOT even with the Baf- fle Board in the front.

Baffle Board

Ceramic Blanket

Back of Firebox

Ceramic Blanket and Baffle Board MUST be in contact with the back of the firebox and even with each other in the front.

Figure 29.1

Baffle Board

Ceramic Blanket is bunched up at the back of the firebox and NOT even with the Baffle Board in the front.

Figure 29.2

September 1, 2008

7033-277F

Page 29

Image 29

Hearth and Home Technologies 31M-ACC-MBK Incorrect Positions, Wood Stove Series ACC Correct Baffle & Blanket Placement

Contents

Hot glass will cause burns Step Top Uni-Body Model Millennium Model7033-277F September 1 007 Wood Stove Series ACCSerial No Model Name Mfg. Date 7033-277F September 1 Table of Contents Glass Specifications Appliance Certification BTU & Efficiency SpecificationsListing and Code Approvals Mobile Home Approved Getting Started Fire Safety 7033-277F September 1 Wood Stove Series ACC Negative Pressure Venting Systems Wood Stove Series ACC Flue Draft ConsiderationsTools And Supplies Needed Inspect Appliance & Components and Pre-Use Check List Masonry Chimney Wood Stove Series ACC Typical Stove Systems Millennium Model Dimensions and ClearancesAppliance Dimensions 10-/8 in mm 21-1/8 in 7mm 7033-277F September 1 11/16 in mm11/16 in mm 89mm Back of Stove to Glass Double Wall Pipe Wood Stove Series ACC Clearances to Combustibles UL and ULC 31004Wood Stove Series ACC InstallationHearth Protection Requirements Millennium Model Wood Stove Series ACC Step-Top Uni-Body Model Fire Risk Asphyxiation Risk Wood Stove Series ACC Outside Air Kit InstallationItems Needed for Installation not supplied Shock Risk Wood Stove Series ACC Blower Optional Chimney Requirements Chimney ConnectorVenting Components Chimney Systems Thimble Air Clearances ComponentsInstructions Solid Pack Chimney with Metal Supports as a Thimble Chimney Height / Rise and Run Installing Chimney ComponentsSolid Pack Chimney with Metal Supports as a Thimble Cont’d Rule Wood Stove Series ACC Chimney Termination RequirementsPitched Roof Flat Roof Mobile Home Installation Begin installing the ARS System Appliance Set Up Finishing the ARS Installation Installing Pedestal Assembly Corners. Figure Installing Leg Kit Adjusting The Blower Speed Control Wood Stove Series ACC Door Handle Assembly Over-Firing Your Appliance Wood Selection & Storage Cont’d Operating InstructionsWood Selection & Storage Burning Process Air Controls Automatic Combustion Control ACC Burn Rates and Operating Efficiency Wood Stove Series ACC Building a Fire Incorrect Positions Wood Stove Series ACC Correct Baffle & Blanket Placement Initial cold start-up and all Burn Settings Frequently Asked Questions Opacity SmokeWood Stove Series ACC Blower Operating Instructions Snap Disc Location Ash Removal System ARS Operating and Cleaning General MaintenanceCreosote Chimney Cleaning Maintaining & Servicing Your Appliance Cleaning Plated Surfaces Glass Cleaning Frequency As desiredWhen cleaning glass Disposal of Ashes Wood Stove Series ACC Glass Replacement Appliance without firebrick Wood Stove Series ACC Firebrick ReplacementTo your authorized dealer Brick Size Qty Snap Disc Location Wood Stove Series ACC Baffle Removal Snap Disc Replacement Replacing Tube Channel Assembly Wood Stove Series ACC Tube Channel Assembly ReplacementRemoving Tube Channel Assembly Start Fire Problems Possible Cause Solution Troubleshooting Exploded view Reference Materials #29 Ceramic Blanket 19 w x 13-3/4 h, 1/2 thick #33 Baffle Board 2 w x 13-3/4 h, each Flue Collar can’t replace in the field Step-Top Uni-Body Model Blower Assembly Wood Stove Series ACC Service Parts & Accessories Item # Service Parts Item # Service Parts Date of Service Performed By Description of Service Wood Stove Series ACC Service And Maintenance Log Wood Stove Series ACC Homeowner’s Notes CONDITIONS, Exclusions & Limitation of Liability September 1 7033-277F Contact Information