Hearth and Home Technologies 31ST-ACC owner manual C. Firebrick Replacement, Wood Stove Series ACC

3100 Wood Stove Series (ACC)												R
C. Firebrick Replacement
Replace the firebrick if they become crumbly and/or if there									1	1
is a 1/4 inch (6.35mm) gap between the bricks.
Inspect the firebrick after each ash removal.							1					1
The firebox is lined with high quality firebrick, which has
exceptional insulating properties. There is no need to use a							1		1		1	1
grate; simply build a fire on the firebox floor. Do not operate
									No brick, ARS
appliance without firebrick.								4			4
						1			Grate Location			1
1. After the coals have completely cooled, remove all old
						5
	brick and ash from unit and vacuum firebox.						2		2	2	2	3
2. Remove new brick set from box and lay out to diagram
	shown.
3.	Lay bottom bricks in unit.									9 in.
4. Install rear bricks on the top of the bottom bricks. Slide							1-1/4 in.				1-1/
										3
	top of bricks under clip on back of firebox wall and push
5.	bottom of brick back.									5 in.
	Install side bricks. Slide top of brick under clips on side								2 in.		2 in.
	of firebox and push the bottom of the brick until it is flush
	with the side of the appliance.
										8 in.
		1		1			1-1/4 in.			5	3 in.
	1				1
	1	1		1	1	Figure 34.2 - 3100 Step Top Brick Assembly
		1
	1			1	1
	4	2	2	2		No.			Brick Size			Qty
	2				3
						1	9 x 4-1/2	x 1-1/4				10
						2	6 x 4-1/2					4
			9 in.			3	9 x 4-1/2 with angle (see drawing)					1
	1-1/4 in.			1-1/		4	4-1/2 x 4-1/2 x 1-1/4					2
			3			5	9 x 3 with angle (see drawing)					1
		2 in.	5 in.	2 in.
			8 in.			Use Part 832-0550 when ordering individual brick. Provide brick
						dimension or copy this page, mark the desired brick and take it
			4	3 in.		to your authorized dealer.
	1-1/4 in.
Figure 34.1 - 3100 Millennium Brick Assembly

No.	Brick Size	Qty
1	9 x 4-1/2 x 1-1/4	12
2	6 x 4-1/2	4
3	9 x 4-1/2 with angle (see drawing)	1
4	9 x 3 with angle (see drawing)	1

NOTE: The Ash Removal System is avail- able for the Step Top Model only and not for the Millennium Model.

Page 34 7033-277F September 1, 2008